|
|||||||||||||||||
|
|
EID Home | Ahead of Print | Past Issues | EID Search | Contact Us | Announcements | Suggested Citation | Submit Manuscript PDF Version | Download Adobe Acrobat | Comments | Email this article |
Synopsis Salmonella Control Programs in DenmarkHenrik C. Wegener,* Tine Hald,* Danilo Lo Fo Wong,* Mogens Madsen,*
Helle Korsgaard,* Flemming Bager,* Peter Gerner-Smidt,† and Kåre Mølbak†
Salmonellosis is one of the most common causes of foodborne diarrheal disease worldwide. Most of these infections are zoonotic and are transmitted from healthy carrier animals to humans through contaminated food. The main reservoir of zoonotic Salmonella is food animals, and the main sources of infections in industrialized countries are animal-derived products, notably fresh meat products and eggs. In developing countries, contaminated vegetables, water, and human-to-human transmission are believed to contribute to a comparatively larger proportion of the human cases than those in industrialized countries (1). However, the incidence of human salmonellosis increased in most industrialized countries in the 1980s and 1990s. Rapid spread of a limited number of successful Salmonella clones in different sectors of food animal production (swine, broiler chickens, and particularly layer hens) has been suggested as the most important cause of this increase (2). Despite much research and many national and international attempts to implement control strategies, the incidence of human salmonellosis in most countries remains high. One notable exception is Sweden, which remains essentially free from the Salmonella problems typical for most other industrialized countries. The background for the Swedish success has been described (3). Unfortunately, other countries cannot apply the Swedish model of Salmonella control, which requires near freedom from Salmonella in domestic food animal production from the onset. In the European Union, the Zoonosis Directive (4) was an attempt to initiate a European Union–wide control effort against foodborne zoonoses, particularly Salmonella in broiler chickens and layer hens. Most European Union countries found that they either could not or would not implement the directive, which did not permit use of vaccines, antimicrobial drugs, or both as elements in the control program of Salmonella in broiler chickens or layer hens. This constraint was seen as an obstacle by some countries. Recently a new directive has been formulated, which is awaiting final approval by the European Union Parliament. In Denmark, the incidence in human salmonellosis increased rapidly in the second half of the 1980s because of the spread of Salmonella in broiler chickens. This increase led to the initiation of a targeted national control program (5). Subsequent spread of Salmonella in swine and layer hens has also led to increases in human disease incidence and subsequently to the development and implementation of targeted control efforts (6–8). We review Denmark’s Salmonella control programs and the effect on Salmonella in food animals, food, and humans. We also evaluate and discuss control costs and public health economy aspects. Control of Salmonella in Broiler ChickensObjectives, Program, and EffectsThe initial aim of the program was that <5% of broiler flocks would be infected with Salmonella. The program was successful and was gradually revised towards assurance of complete freedom from Salmonella in broiler production. The program is based on the principle of top-down eradication, ensuring freedom from Salmonella from the top of the broiler-breeding pyramid down. Infected flocks of breeding animals are destroyed, and infected birds are processed for slaughter. The testing program has developed gradually to adjust to higher food safety objectives. As progress stalled, more intensive serologic and bacteriologic testing was developed and applied (5,9–11). The current testing scheme is shown in Table 1. Birds from infected flocks are slaughtered on separate slaughter lines or late in the day to avoid cross-contamination. Farmers get a better price for birds from Salmonella-free flocks, and slaughterhouses can use the label “Salmonella-free” for birds that meet criteria determined by the authorities. No decontaminants, such as organic acids or chlorine, are used during carcass processing.
The proportion of Salmonella-infected broiler flocks has been markedly reduced since the initiation of the control program. Figure 1 shows that >65% of broiler flocks tested positive for Salmonella during the first year of the program, 1988–89, versus <5% in 2000. This decrease in Salmonella has led to a concomitant reduction in the proportion of infected broiler carcasses after slaughter and at retail. The Danish government and the European Union equally compensate owners of destroyed breeding stock for their losses. In 1993, a major Danish retailer (COOP-Denmark) stopped the marketing of broiler chicken, which exceeded a 5% target. Danish chicken could not meet this target at that time, so producers suffered severe losses because they had to export their chicken to lower priced markets. Salmonella can be effectively reduced (nearly eliminated) from broiler chickens by intensive flock-level testing and top-down eradication. Essential to success is a sufficiently sensitive testing program in the breeding and rearing flocks as well as in the hatcheries, i.e., one that involves intensive sampling and a combination of serologic and bacteriologic testing methods (Table 1). Bacteriologic testing alone is not sufficiently sensitive to achieve control, especially if S. Enteritidis infections are present. Removal of all organic material, thorough cleaning and disinfection of the poultry house, and an empty resting period of 10–14 days between flocks can effectively eliminate residual infections. In Denmark, most infections appear to be vertically transmitted (nearly always traceable to an infected hatchery or parent flock), whereas horizontal transmission from the environment and wild fauna appear to play a minor role. Competitive exclusion cultures, vaccines, or antibiotics have not been used in the Danish control program. Control of Salmonella in Layer HensObjectives, Program, and EffectsAll shell eggs from commercial layer flocks should be free from S. Enteritidis and S. Typhimurium. Control of layer breeders in Denmark is essentially identical to the control program for broiler breeders (Table 1). Blood and fecal samples of rearing flocks are tested (8,11), and infected flocks are destroyed. All commercial flocks of layer hens in production are tested routinely every 9 weeks by a combination of serologic testing of egg yolk and bacteriologic testing of environmental samples (Table 1, Figure 2). All eggs from suspect or confirmed-positive layer flocks are pasteurized. All shell eggs are distributed in a cold chain (not exceeding 12°C) and kept refrigerated at retail; eggs are generally refrigerated in private homes. The government and the European Union equally compensate owners of destroyed breeding stock for their losses. The proportion of layer flocks infected with Salmonella, notably S. Enteritidis, has been markedly reduced since the initiation of the control program. Figure 3 shows that >7% of layer flocks tested positive for Salmonella in the first year of the program, 1998, versus <2% in 2001. The level of Salmonella-contaminated shell eggs has not been measured from the initiation of the control program. However, a year before the program began, a study of 13,000 eggs from different types of production determined the level to be 1 per 1,000 eggs (20% of the contaminated eggs harbored S. Enteritidis) (12). Top-down eradication of S. Enteritidis has effectively reduced the level of Salmonella, notably S. Enteritidis, in Danish commercial layer flocks. The program has been effective in free range, deep litter, organic, and caged birds. Frequent testing by a combination of serologic and bacteriologic testing methods is essential to achieve adequate sensitivity in the monitoring program. Control of residual infections in poultry houses can be conducted with a success rate of nearly 70% by thorough cleansing and disinfection of the depopulated house (removal of all organic material, disinfection of surfaces, and resting of the empty house for 2 weeks). Day-old chicks for rearing must be antibiotic free. Competitive exclusion cultures and vaccination are not used in the Danish program. Vaccination cannot, at present, be used in combination with serologic testing because of problems of cross-reaction. Control of Salmonella in PorkObjectives, Program, and EffectsDenmark is the only country with a nationwide control program of Salmonella in pork that is integrated from “feed-to-food.” The program is based on routine testing and classification of slaughter pig herds and subsequent slaughter of pigs according to the inherent risk, as measured by the continual test program (Figure 2; Table 2). The program has been described in detail elsewhere (7,8,13). Pre-Harvest ControlPigs from breeding and multiplying herds are tested monthly by serologic testing of blood samples. If a specific cutoff level is reached, bacteriologic confirmatory testing is carried out. Further, if the serologic reactions exceed a specific high level, all movement of animals is restricted. Slaughter pig herds are monitored continuously by serologic testing of “meat juice” (drip fluid released from meat after freezing and thawing) (14). Meat samples for testing are collected at the slaughter line, and the number of samples and frequency of sampling are determined by the size of the herd. Approximately 700,000 slaughter pigs are currently tested each year (Figure 4). Herds sending <200 pigs to slaughter each year are not tested, leaving 1.6% of the slaughter pigs outside the monitoring scheme (13). The herds are categorized in three levels based on the proportion of seropositive meat juice samples during the last 3 months. Owners in level 2 and 3 are encouraged to seek advice on how to reduce the Salmonella problem in the herd (e.g., feeding, hygiene, and management). Furthermore, payment from the slaughterhouse is reduced by 2% and 4%, respectively. The postharvest surveillance program has been described (8,15,16). Pigs from herds in levels 1 and 2 are slaughtered traditionally without any special precautions. Pigs from level 3 herds can only be slaughtered in special slaughterhouses under special hygienic precautions. Carcasses from level 3 herds are tested for bacteria after slaughter, and if the level of contamination exceeds a certain limit all carcasses from the particular herd have to undergo heat treatment or other risk-reducing processing. All slaughterhouses do routine bacteriologic testing of carcasses according to a sampling plan, which ensures that testing is random and representative of the national swine production (>30,000 samples/year). Slaughterhouses that exceed a certain predetermined level of Salmonella in the routine monitoring of carcasses are obliged to investigate and reduce the contamination problem to an acceptable level. The prevalence of swine herds in level 2 and 3 respectively, has been steadily reduced since the program began (Figure 5). Bacteriologic testing has indicated that the herd infection level was reduced by 50% (from 14.7% to 7.2% in small herds and 22.2% to 10.4% in large herds) from 1993 (when the program was implemented) to 1998 (17). In the same period, the level of Salmonella contamination in pork products, as determined by the routine monitoring program, was reduced from 3% to <1% (Figure 6). As Salmonella eradication in swine herds is difficult because of the continual nature of the production system, reducing the infection level should be the aim of a control strategy. The low infection level in the herds and contamination in the products can likely be reduced further in Denmark. As the contamination level goes below 1%, testing for contamination requires increasingly large numbers of samples and consequently becomes very expensive, which is one reason the sampling plan of herds and products has become more sensitive in recent years. This change in testing sensitivity makes it difficult to compare current and past levels of infection and contamination but is nevertheless a necessity for the continued improvement of the program. A combination of serologic and bacteriologic testing is essential for the success of the program. Nearly 1 million serologic samples are tested each year. Testing this large number of samples would not be possible because of financial and logistic constraints if the program were to rely on bacteriologic testing alone. Feeding strategy (e.g., increased coarseness of feed and wet feeding) and improved management (e.g., sectioning and all-in all-out production) and hygiene standards are important elements in the preharvest control efforts. Using commercial prebiotic cultures is not necessary; natural microflora in the feed, especially wet fermented feed, appear to have a protective effect (18). A reduction of Salmonella in slaughter pig herds has been attained without Salmonella–free breeding herds. However, to ensure the highest degree of consistency in the program, the levels of Salmonella in breeding herds should be kept as low as possible, and infected breeding herds should not be sold to producers of herds of a superior Salmonella status. Determination of Public Health ImpactTo better explain the mechanisms in the occurrence of Salmonella infections in humans, the Danish Zoonosis Centre has previously described a method that estimates the number of human cases attributable to each of the major animal-food sources (19,20). Using this method, we compared Salmonella types isolated from animals and foods with Salmonella types isolated from humans. In brief, subtypes of Salmonella that are almost exclusively found in a particular food animal reservoir or food type (unique types) are used as anchor points for the distribution of subtypes occurring in several reservoirs and sources. All human infections caused by the unique types are associated with the indicated food type or derived from the indicated food animal reservoir (e.g., pork, beef, chickens, or eggs). Salmonella types, which occur in several reservoirs, are distributed relative to the prevalence of unique types in each reservoir or food type. Detailed knowledge of the distribution of Salmonella types in all relevant food animals and food types, generated through intensive and continuous monitoring, is a prerequisite for the analysis. Recently, a stochastic model based on the principles of the previous method was developed and applied. This model allows us to consider the uncertainty around the estimated parameters (21). Figure 7 shows the human salmonellosis incidence associated with the three major sources of human salmonellosis in Denmark from 1988 to 2001. The year that a control program was launched for a specific food animal production system is also indicated. The control programs have been successful in achieving the main objective, a reduction of the incidence of human salmonellosis. The broiler-associated salmonellosis incidence (cases/100,000) has been reduced by >95.0, from 30.8 in 1988 to 0.5 in 2001; the pork-associated salmonellosis incidence has been reduced by >85, from 22.0 in 1993 to 3.0 in 2001; and the egg-associated salmonellosis incidence has been reduced by nearly 75, from 57.7 in 1997 to 15.5 in 2001. Trends in the animal and food-specific disease incidence estimates show a high degree of agreement with the trends in prevalence of Salmonella in specific food animals and the corresponding animal-derived food products. These trends serve as an indirect validation of the estimates because these estimates do not rely on prevalence data. Economy of Salmonella ControlCosts of Salmonella ControlThe Audit Office of Denmark has evaluated the government spending in relation to the national Salmonella control efforts (22). From 1994 to 1999, the control program for broiler chickens and layer hens involved government finances of a total of 188.1 million Danish kroner (DKK) (U.S.$26.5 million) (U.S.$1.00 = 7.1 DKK). A total of 109.7 million DKK (U.S.$15.45 million) was paid to compensate farmers for destroyed animals; most of the remaining costs were associated with establishing and running the surveillance program. These costs were highest in the initial phase of the layer hen control program in 1997 but have been reduced considerably since then. In 2001, all costs associated with running the program were assumed by the poultry industry (with the exception of governments’ compensation for flocks destroyed according to the European Union Zoonosis Directive). The current control costs for layer hens and broiler chickens are estimated to be in the range of US$4.2 million per year (for 344 broiler producers, producing 135 million broiler chickens year, and 392 shell-egg producers, producing 1 billion shell-eggs per year). In the initial phase, the Salmonella control program of pigs and pork cost the industry and government a total of U.S.$14 million per year. With the recent revision of the program, the responsibility has been taken over solely by the industry, and operational costs have been reduced to approximately U.S.$8.5 million per year (for 21,000 producers, producing 21–22 million slaughter pigs each year) (B. Nielsen, pers. comm.). Public Health EconomyDirect health costs (e.g., hospitalization, consulting a physician, and laboratory testing) as well as the costs of lost labor (e.g., loss of production per day away from work) in relation to a case of salmonellosis in Denmark were evaluated as part of a multidisciplinary task force (Korsgaard and Wegener, pers. comm.). For 2001, foodborne salmonellosis cost the Danish U.S.$15.5 million. The estimate is based on an incidence of 54.6 cases per 100,000, and approximately 10% of cases are laboratory confirmed. Assuming that 5% or 20% of cases are laboratory-confirmed changes the estimate to U.S.$25.5 million and U.S.$10.4 million, respectively. Costs and BenefitsAssuming that salmonellosis associated with each of the major sources would have remained at the precontrol program incidence (and not increased further) (i.e., if no action had been taken to curb the problem), we calculated a hypothetical “no-control” salmonellosis incidence. This incidence would have been 137.5 (pork 22, broiler chickens 30.8, eggs 57.7, and average residual, 27). The societal costs, in the absence of the existing control programs, would thus have been U.S.$41 million per year (assuming 10% of cases are laboratory confirmed). Thus, in 2001, Denmark saved U.S.$ 25.5 million by controlling Salmonella. The estimated annual Salmonella control costs from 2000 and onwards are approximately U.S.$14.1 million. These costs are borne almost exclusively by the animal producers and the food industry, which suggests that the costs are passed on to consumers through higher food prices. Based on the figures above and data on annual production (23), control costs amount to approximately U.S.$0.075/kg of pork and U.S.$0.02/kg of broiler or egg. DiscussionDanish Salmonella control efforts have been successful in achieving their objective; reduction of human salmonellosis. These efforts illustrate that with a focused and integrated programs, including a strong element of preharvest control, and based on a public-private partnership, Salmonella can be reduced. At the same time, the industries involved have remained profitable and internationally competitive (approximately 75% of the chicken products and 85% of the pork are exported). Initially, the programs have received some government funding, primarily for research, development, and compensation for destroyed animals. After the initial implementation and clean-up phase of the programs, the responsibility for running and funding the programs have been nearly completely taken over by the industries involved. The government, however, maintains access to all relevant information and data through a central database managed by the Danish Zoonosis Centre, and food safety objectives continue to be determined by the Danish government. A proactive and collaborative approach to food safety by food industry and government ensures consumers’ confidence in the domestic food production. For example, when the bovine spongiform encephalopathy (BSE) crisis hit Europe, the beef industry in most countries was adversely affected by reduced consumer demand. In Denmark, the sale of beef remained nearly unaffected by the crisis even after the first positive BSE findings occurred in Danish cattle. These steady beef sales are likely attributable to a high degree of consumer confidence in the public and private control systems. The success of the programs supports the effectiveness of a preharvest control approach to Salmonella. Monitoring and intervention at the farm and in the food animal breeding systems are feasible means to achieve lasting control of the Salmonella problem. Development and application of a two-tiered detection system based on a combination of serologic testing and bacteriologic confirmation have been essential for the success of the programs. Serologic testing enables semi-automated mass screening of animals and eggs at a low price and with good, and in some cases superior, sensitivity. Bacteriologic testing serves to compensate for the sub-optimal specificity of a serologic-based monitoring system. The programs could not have been operated solely on the basis of bacteriologic testing because of the higher costs involved and logistical problems (i.e., screening nearly 2 million samples per year by bacteriologic testing is unrealistic). Preharvest control tools, such as vaccines, antibiotics, or competitive exclusion, are not used to control Salmonella in Denmark; these tools might be counterproductive, as they mask the Salmonella problem rather than aid in its reduction or eradication. Evaluating the costs and benefits of the national Salmonella control efforts is difficult; estimating the public health and societal costs in the absence of the control program is impossible. However, this conservative estimate suggests that efforts have been cost beneficial and those benefits are likely to increase with time.
References
|
|
||||||||||||
|
||||||||||||
|
EID Home | Top of Page | Ahead-of-Print | Past Issues | Suggested Citation | EID Search | Contact Us | Accessibility | Privacy Policy Notice | CDC Home | CDC Search | Health Topics A-Z |
||
This page posted June
11, 2003 |
||
Emerging
Infectious Diseases Journal |
||