|
Acute Management Overview
- Chlorine is a yellow-green, noncombustible gas with a pungent, irritating odor. Chlorine's odor or irritant properties are discernible by most individuals at 0.32 ppm, which is less than the OSHA permissible exposure limit (PEL) of 1 ppm. Chlorine's odor or irritant properties generally provide adequate warning of hazardous concentrations. It is a strong oxidizing agent and can react explosively or form explosive compounds with many common substances. Chlorine is heavier than air and may collect in low-lying areas.
- Responders should obtain assistance in identifying the chemical(s) from container shapes, placards, labels, shipping papers, and analytical tests. General information on these identification technicques is located in Emergency Response Guidebook.
- Identification Tools - CHEMM-IST, WISER, Chlorine Chemical Properties
- Devices - Chemical Agent Detector C2 Kit (liquid and vapor), Draeger CDS Kit (vapor and aerosol), Hazmat Smart Strips (qualitative)
- A comprehensive source for the selection of chemical identification equipment is the Guide for the Selection of Chemical Detection Equipment for Emergency First Responders, Guide 100-06, January 2007, 3rd Edition, published by the Department of Homeland Security to assist with this process.
- Persons exposed only to chlorine gas generally do not pose substantial risks of secondary contamination.
- However, clothing or skin soaked with industrial-strength chlorine bleach or similar solutions may be corrosive to rescuers and may release harmful chlorine gas.
- PPE required; Level B-C is generally adequate depending on the ambient temperature and distance from hot/warm zones. (bring in HAZMAT for Level As PRN) Use butyl rubber or other glove materials with adequate breakthrough characteristics. Be aware that use of protective equipment by the provider may cause fear in children, resulting in decreased compliance with further management efforts.
- Link to PPE, rescuer safety hospital management section
- Link to reference section for acute event PPE related safety information
- In a mass casualty situation, asymptomatic patients who are reliable historians and those who experienced only minor sensations of burning of the nose, throat, eyes, and respiratory tract (with perhaps a slight cough) may be released. In most instances, these patients will be free of symptoms in an hour or less. They should be advised to seek medical care promptly if symptoms develop or recur. If the incident involved a small number of patients, or the victims included young children (especially infants or patients with special needs), they should be monitored in an ED "extended care" area for 6-12 hrs.
- Victims exposed only to chlorine gas who have no skin or eye irritation do not need decontamination. They may be transferred immediately to the Support Zone. All others require decontamination.
- Symptomatic patients complaining of persistent shortness of breath, severe cough, or chest tightness should be admitted to the hospital and observed until symptom-free (pulmonary injury may progress for several hours).
- If the treater feels that the patient has been exposed to a significant amount of chlorine, despite a relatively a benign clinical appearance he/she should be admitted for observation.
- Clinical signs of pulmonary edema will typically present 2-4 hours following a moderate exposure and 30 - 60 minutes following a severe exposure.
- Rescue personnel are at low risk of secondary contamination from victims who have been exposed only to chlorine gas.
- However, clothing or skin soaked with industrial-strength bleach or similar solutions may be corrosive to rescuers and may release harmful chlorine gas.
- Victims exposed only to chlorine gas who have no skin or eye irritation do not need decontamination. They may be transferred immediately to the Support Zone. All others require decontamination.
- Link to hospital management section
- Inhalation - most exposures to chlorine occur by inhalation. However, prolonged, low-level exposures, such as those that occur in the workplace, can lead to olfactory fatigue and tolerance of chlorine's irritant effects. Chlorine is heavier than air and may cause asphyxiation in poorly ventilated, enclosed, or low-lying areas.
- Skin/Eye Contact - direct contact with liquid chlorine or concentrated vapor causes severe chemical burns, leading to cell death and ulceration.
- Ingestion - ingestion is unlikely to occur because chlorine is a gas at room temperature. Solutions that are able to generate chlorine (e.g., sodium hypochlorite solutions) may cause corrosive injury if ingested.
Clinical Signs and Symptoms
- Respiratory - being water soluble, chlorine is primarily absorbed by the upper airway. Exposure to low concentrations (1-10 ppm) may cause eye and nasal irritation, sore throat and cough. Inhalation of higher concentrations (> 15 ppm) can very rapidly lead to respiratory distress. This can occur almost immediately with initial symptoms of stridor, followed shortly by wheezing, rales, hemoptysis, and subsequent pulmonary edema. Clinical signs of pulmonary edema will present 2-4 hours following a moderate exposure and 30 - 60 minutes following a severe exposure. Immediate onset of laryngospasm with respiratory arrest can occur.
- Cardiovascular - initial tachycardia and hypertension followed by hypotension may occur.
- Gastrointestinal - ingestion of chlorine can cause significant esophageal and stomach injury. Odynophagia, drooling and refusal of food suggest a more significant injury. Substernal chest pain, abdominal pain and rigidity suggest profound injury and potential perforation of the esophagus and/or stomach.
- Dermal - chlorine causes skin irritation and with sufficient concentration can cause, burning pain, inflammation, and blisters. Liquefied chlorine can cause frostbite injury.
- Ocular - low vapor concentrations can cause burning, redness, conjunctivitis, and tearing. Higher concentrations may result in corneal burns.
- Link to Toxic Syndromes
- Link to Primary and Secondary Survey
- Phosgene is distinguished by its smell in high concentrations and delayed onset of pulmonary edema.
- Chlorine has a characteristic odor even in low concentrations, immediate onset of respiratory distress, bronchospasm, eye, skin, and upper airway irritation.
- Riot agents cause an acute onset of burning sensation in the eyes and upper airway without progression of symptoms. Riot agents do not cause laryngospasm except in high doses and patients never develop symptoms of peripheral pulmonary edema.
- Nerve agents induce watery secretions as well as respiratory distress, but have a host of other symptoms, such as miosis, seizures, rapidity of onset, that can distinguish them from pulmonary agents.
- The respiratory toxicity of vesicants (i.e. mustard) is usually delayed, but affects the central rather than the peripheral airway. Vesicant toxicity severe enough to cause dyspnea typically causes airway necrosis often with upper airway obstruction.
- Link to Chemical Hazards Emergency Medical Management Intelligent Syndromes Tool (CHEMM-IST)
Hot/Warm Zones
Show all sections
Establish hot/warm zones - including hot/warm zones triage, decontamination, re-triage locations.
If contaminated patients arrive at the Emergency Department, they must be decontaminated before being allowed to enter the facility. Decontamination can only take place inside the hospital if there is a decontamination facility with negative air pressure and floor drains to contain contamination.
Rescuers should be trained and appropriately attired before entering the Hot/Warm Zones. If the proper equipment is not available, or if rescuers have not been trained in its use, call for assistance in accordance with local Emergency Operational Guides (EOG). Sources of such assistance should be obtained from a local HAZMAT teams, mutual aid partners, the closest metropolitan strike system (MMRS) and the U. S. Soldier and Biological Chemical Command (SBCCOM)-Edgewood Research Development and Engineering Center. SBCCOM may be contacted (from 7:00 AM - 4:30 PM EST call 410-671-4411 and from 4:30PM - 7:00AM EST call 410-278-5201), ask for the Staff Duty Officer.
Hot/Warm Zones
- Chlorine is a yellow-green, noncombustible gas with a pungent, irritating odor. Chlorine's odor or irritant properties are discernible by most individuals at 0.32 ppm which is less than the OSHA permissible exposure limit (PEL) of 1 ppm. Chlorine's odor or irritant properties generally provide adequate warning of hazardous concentrations. It is a strong oxidizing agent and can react explosively or form explosive compounds with many common substances. Chlorine is heavier than air and may collect in low-lying areas.
- The toxic effects of chlorine are primarily due to its corrosive properties. The action of chlorine is due to its strong oxidizing capability, in which chlorine splits hydrogen from water in moist tissue, causing the release of nascent oxygen and hydrogen chloride which produce major tissue damage. Alternatively, chlorine may be converted to hypochlorous acid which can penetrate cells and react with cytoplasmic proteins to form N-chloro derivatives that destroy cell structure. Symptoms may be apparent immediately or delayed for a few hours.
- Responders should obtain assistance in identifying the chemical(s) from container shapes, placards, labels, shipping papers, and analytical tests. General information on these identification technicques is located in Emergency Response Guidebook.
- Identification Tools - CHEMM-IST, WISER, Chlorine Chemical Properties
- Devices - Chemical Agent Detector C2 Kit (liquid and vapor), Draeger CDS Kit (vapor and aerosol), Hazmat Smart Strips (qualitative)
- A comprehensive source for the selection of chemical identification equipment is the Guide for the Selection of Chemical Detection Equipment for Emergency First Responders, Guide 100-06, January 2007, 3rd Edition published by the Department of Homeland Security to assist with this process.
Respiratory and Skin Protection: Positive-pressure-demand, self-contained breathing apparatus (SCBA) level A is recommended in response situations that involve exposure to potentially unsafe levels of chlorine liquid or vapor.
PPE required level B-C
Most likely B-C PPEs will be adequate. Levels As may be required if the hospital is close to the site of exposure and/or there is concern for vapor exposure (bring in HAZMAT for Level A PPEs).
Respiratory Protection: Positive-pressure, self-contained breathing apparatus (SCBA) is recommended in response situations that involve exposure to potentially unsafe levels of chlorine.
Skin Protection: Chemical-protective clothing is recommended because of the potential of inflammatory and corrosive effects.
- Level A - protective clothing is the highest level of protection. Level A includes a Self Contained Breathing Apparatus (SCBA) with a fully encapsulating vapor tight suit with gloves and booties attached to the suit (tanks last from 1/2 hour to 1 hour).
- Level B - requires the use of SCBA but has less skin protection. Level Bs are chemical resistant suits that are designed for splashes of liquids but not for gas or vapor hazards. A young soldier can last about 2 hours on a hot day with an external air hose.
- Level C is similar to B with the exception of the type of respiratory protection. The SCBA is replaced with an Air Purifying Respirator.
- Level D protective clothing is utilized when there are no respiratory hazard and no major skin hazard considerations. Level D for hospital personnel includes scrubs, safety glasses, shoe covers, and possibly a face shield.
Link to reference section for acute event PPE related safety information
Chemical casualty triage is based on walking feasibility, respiratory status, age, and additional conventional injuries. The triage officer must know the natural course of a given injury, the medical resources immediately available, the current and likely casualty flow, and the medical evacuation capabilities.
Mass Casualty Triage Standards
General Principles of Triage for Chemical Exposures
- Check triage tag/card for any previous treatment or triage.
- Survey for evidence of associated traumatic/blast injuries.
- Observe for sweating, labored breathing, coughing/vomiting, secretions.
- Severe casualty triaged as immediate if assisted breathing is required.
- Blast injuries or other trauma, where there is question whether there is chemical exposure, victims must be tagged as immediate in most cases. Blast victim's evidence delayed effects such as ARDS, etc.
- Mild/moderate casualty: self/buddy aid, triaged as delayed or minimal and release is based on strict follow up and instructions.
- If there are chemical exposure situations which may cause delayed but serious signs and symptoms, then over-triage is considered appropriate to the proper facilities that can observe and manage any delayed onset symptoms.
- Expectant categories in multi-casualty events are those victims who have experienced a cardiac arrest, respiratory arrest, or continued seizures immediately. Resources should not be expended on these casualties if there are large numbers of casualties requiring care and transport with minimal or scant resources available.
- In a given category prioritize a child, pregnant woman over a non-pregnant adult.
- In a mass casualty situation, asymptomatic patients who are reliable historians and those who experienced only minor sensations of burning of the nose, throat, eyes, and respiratory tract (with perhaps a slight cough) may be released. In most instances, these patients will be free of symptoms in an hour or less. They should be advised to seek medical care promptly if symptoms develop or recur. If the incident involved a small number of patients, or the victims included young children (especially infants or patients with special needs), they should be monitored in an ED "extended care" area for 6-12 hrs.
- Victims exposed only to chlorine gas who have no skin or eye irritation do not need decontamination. They may be transferred immediately to the Support Zone. All others require decontamination.
- Symptomatic patients complaining of persistent shortness of breath, severe cough, or chest tightness should be admitted to the hospital and observed until symptom-free (pulmonary injury may progress for several hours).
- If the treater feels that the patient has been exposed to a significant amount of chlorine, despite a relatively a benign clinical appearance he/she should be admitted for observation.
- Clinical signs of pulmonary edema will typically present 2-4 hours following a moderate exposure and 30 - 60 minutes following a severe exposure.
Quickly ensure that the victim has a patent airway. Maintain adequate circulation. If trauma is suspected, maintain cervical immobilization manually and apply a decontaminable cervical collar and a backboard when feasible. Apply direct pressure to stop arterial bleeding, if present.
- Inhalation - most exposures to chlorine occur by inhalation. However, prolonged, low-level exposures, such as those that occur in the workplace, can lead to olfactory fatigue and tolerance of chlorine's irritant effects. Chlorine is heavier than air and may cause asphyxiation in poorly ventilated, enclosed, or low-lying areas.
- Skin/Eye Contact - direct contact with liquid chlorine or concentrated vapor causes severe chemical burns, leading to cell death and ulceration.
- Ingestion - ingestion is unlikely to occur because chlorine is a gas at room temperature. Solutions that are able to generate chlorine (e.g., sodium hypochlorite solutions) may cause corrosive injury if ingested.
Clinical Signs and Symptoms
Respiratory
- Chlorine gas - being water soluble, is primarily absorbed by the upper airway. Exposure to low concentrations (1-10ppm) may cause eye and nasal irritation, sore throat and cough. Inhalation of higher concentrations (> 15 ppm) can very rapidly lead to respiratory distress. This can occur almost immediately with initial symptoms of stridor, followed shortly by wheezing, rales, hemoptysis, and subsequent pulmonary edema. Clinical signs of pulmonary edema will present 2-4 hours following a moderate exposure and 30 - 60 minutes following a severe exposure. Immediate onset of laryngospasm with respiratory arrest can occur.
Cardiovascular
- Initial tachycardia and hypertension followed by hypotension may occur.
Gastrointestinal
- Ingestion of chlorine can cause significant esophageal and stomach injury. Odynophagia, drooling and refusal of food suggest a more significant injury. Substernal chest pain, abdominal pain and rigidity suggest profound injury and potential perforation of the esophagus and/or stomach.
Acidosis
- May result from hypoxia. Following a massive chlorine inhalation an excessive amount of chloride ions can end up in the blood. Because of their higher metabolic rate children are more vulnerable to toxicants interfering with their metabolism.
Dermal
- Chlorine can cause skin irritation and with sufficient concentration can cause burning pain, inflammation, and blisters. Liquefied chlorine can cause frostbite injury.
Ocular
- Low vapor concentrations can cause burning, redness, conjunctivitis, and tearing. Higher concentrations may result in corneal burns.
Link to Toxic Syndromes
Link to Primary and Secondary Survey
- Phosgene is distinguished by its smell in high concentrations and delayed onset of pulmonary edema.
- Chlorine has a characteristic odor even in low concentrations, immediate onset of respiratory distress, bronchospasm, eye, skin, and upper airway irritation.
- Riot agents cause an acute onset of burning sensation in the eyes and upper airway without progression of symptoms. Riot agents do not cause laryngospasm except in high doses and patients never develop symptoms of peripheral pulmonary edema.
- Nerve agents induce watery secretions as well as respiratory distress, but have a host of other symptoms, such as miosis, seizures, rapidity of onset, that can distinguish them from pulmonary agents.
- The respiratory toxicity of vesicants (i.e. mustard) is usually delayed but affects the central rather than the peripheral airway. Vesicant toxicity severe enough to cause dyspnea typically causes airway necrosis often with upper airway obstruction.
- Link to Chemical Hazards Emergency Medical Management Intelligent Syndromes Tool (CHEMM-IST)
Pediatric/Obstetric/Geriatric Vulnerabilities
Children are more vulnerable to chlorine because:
- Infants, toddlers, and young children do not have the motor skills to escape from the site of an incident.
- The high vapor density of gases places their highest concentration close to the ground which is in the lower breathing zone of children.
- Exposure may be greater due to the higher number of respirations per minute in children.
- The smaller airway diameter, anatomic subglottic narrowing, omega shaped epiglottic structure, relatively large tongue size, less rigid ribs and trachea make them more vulnerable to pulmonary agent induced pathology, i.e. stridor, bronchospasm, copious secretions.
- Their skin is thinner and has more moisture content, therefore being more vulnerable to the inflammatory effects of corrosive agents as well as increased toxin absorption
- Having less fluid reserve increases the child's risk of rapid dehydration or shock after vomiting and diarrhea.
- Children exposed to chlorine are likely to experience increased severity of the same clinical effects seen in exposed adults.
- Link to Primary and Secondary Survey
Treatment in the Hot/Warm Zones
Antidotes - there are no specific antidotes for chlorine.
Supportive
Intubate the trachea in cases of coma or respiratory compromise. If not possible, perform cricothyroidotomy or place 14 gauge angiocatheter in crico-thyroid membrane (if equipped and trained to do so).
Link - placement of 14 gauge angiocatheter in cricothryroid membrane
Treat patients who have bronchospasm with aerosolized bronchodilators. The use of bronchial sensitizing agents in situations of multiple chemical exposures may pose additional risks. Consider the health of the myocardium before choosing which type of bronchodilator should be administered. Cardiac sensitizing agents may be appropriate; however, the use of cardiac sensitizing agents after exposure to certain chemicals may pose enhanced risk of cardiac arrhythmias (especially in the elderly). Chlorine poisoning is not known to pose additional risk during the use of bronchial or cardiac sensitizing agents.
Consider racemic epinephrine‡ aerosol for children who develop stridor. Dose 0.25 - 0.75 mL of 2.25% racemic epinephrine solution in 2.5 cc water, repeat every 20 minutes as needed, cautioning for myocardial variability.
Patients who are comatose, hypotensive, or are having seizures or cardiac arrhythmias should be treated according to advanced life support (ALS) protocols.
Frostbite - Always handle frostbitten skin and eyes with caution. Place frostbitten skin in warm water (108 degrees). Do not allow the skin to touch the sides of the container. If hot water is not available wrap the affected area gently in warm blankets. Encourage exercise of the affected part while it is being warmed.
‡ Not FDA approved for this indication/Off-label use
If victims can walk, lead them out of the Hot/Warm Zones to the Decontamination Zone (they should not walk long distances if at all possible as physical exertion may worsen and/or accelerate the development of non-cardiogenic pulmonary edema). Victims who are unable to walk may be removed on backboards or gurneys; if these are not available, carefully carry or drag victims to safety. Should there be a large number of casualties, and if decontamination resources permit, separate decontamination corridors should be established for ambulatory and non-ambulatory victims.
Consider appropriate management of chemically contaminated children, such as measures to reduce separation anxiety if a child is separated from a parent or other adult.
Decontamination Zone
Show all sections
Victims exposed only to chlorine gas who have no skin or eye irritation do not need decontamination. They may be transferred immediately to the Support Zone. All others require decontamination. Rescue personnel are at low risk of secondary contamination from victims who have been exposed only to chlorine gas. However, clothing or skin soaked with industrial-strength bleach or similar solutions may be corrosive to rescuers and may release harmful chlorine gas.
Decontamination Zone
Personnel should continue to wear the same level of protection as required in the Hot/Warm Zones.
Link to Hot/Warm Zones - Rescuer Protection.
If exposure levels are determined to be safe, decontamination may be conducted by personnel wearing a lower level of protection than that worn in the Hot/Warm Zones. However, do not attempt resuscitation without a barrier.
If warranted immediately institute emergency life support measures. Treatment should be given simultaneously with decontamination procedures. Quickly ensure that the victim has a patent airway and is ventilating well. Assist ventilation with a bag-valve-mask device equipped with a canister or air filter, if necessary. Maintain adequate circulation. Stabilize the cervical spine with a decontaminable collar and a backboard if trauma is suspected. Direct pressure should be applied to control heavy bleeding, if present.
Antidotes - there are no specific antidotes for chlorine.
Set up Considerations
- Use pictorial and written posted instructions for victims to self decon when able, use locale-appropriate multilingual signage
- Double bag contaminated clothing etc. (place hearing aids, valuables in small bag). Place bag in container by showers.
- Victims who are able may assist with their own decontamination.
- Children and the elderly are at increased risk for hypothermia - provide warm showers, blankets.
- Privacy must be considered, if possible.
- The decontamination system should be designed for use in children of all ages, by parentless children, the non-ambulatory child, the child with special needs, and also allow families to stay together.
- Use step-by-step, child friendly instructions that explain to the children and parents what they need to do, why they are doing it, and what to expect.
- Take into consideration that infants when wet are slippery and will need a way to get them through the decontamination process - i.e. plastic buckets, car seats, stretchers...
- Designate a holding area and provide staff to support and supervise the children
- Recommended age-appropriate staffing ratios for untended children:
- 1 adult to 4 infants
- 1 adult to 10 preschool children
- 1 adult to 20 school-age children
Washing Instructions
- If there will be significant delay to decontamination, have the victims rinse off with water exposed skin surfaces and disrobe (disposable clothing kits should be available).
- Remove all clothing (at least down to their undergarments) and place the clothing in a labeled durable 6-mil polyethylene bag (removal of clothing, at least to the undergarment level will reduce victim's contamination by 85%).
- If clothes have been exposed to contamination, then care must be taken when undressing to avoid transferring chemical agents to the skin - i.e. any clothing that has to be pulled over your head should be cut off instead of being pulled over your head.
- If exposure to liquid agent is suspected, cut and remove all clothing and wash skin immediately with soap and water.
- If exposure to vapor only is certain, remove outer clothing and wash exposed skin with soap and water.
- Cover all open wounds with plastic wrap prior to performing head-to-toe decontamination (particular attention should be made to open wounds because cyanide is readily absorbed through abraded skin).
- Flush the exposed skin and hair with plain water for 2 to 3 minutes then wash twice with mild soap. Rinse thoroughly with water. Be careful not to break the patient/victim's skin during the decontamination process.
- Flush exposed or irritated eyes with plain water or saline for at least 15 minutes by tilting the head to the side, pulling eyelids apart with fingers, and pouring water slowly into eyes. Remove contact lenses if easily removable without additional trauma to the eye. If a corrosive material is suspected or if pain or injury is evident, continue irrigation while transferring the victim to the Support Zone.
- Do not irrigate eyes that have sustained frostbite injury.
- Scraping with a wooden stick, i.e. a tongue depressor or popsicle stick, can remove bulk agent.
- Caution - many people shower as they do it at home rather than conducting a rapid decontamination of their bodies. Too aggressive scrubbing can lead to further damage to skin and open wounds.
- Utilizing large amounts of water by itself is very effective (limit pressure in infants).
- If water supplies are limited, and showers are not available, an alternative form of decontamination is to use absorbent powders such as flour, talcum powder, or Fuller's earth.
- Certification of decontamination is accomplished the following: processing through the decontamination facility; utilization of a device designed for confirmation of successful decontamination such as a Chemical Agent Detector C2 Kit.
A comprehensive source for the selection of chemical identification equipment is the Guide for the Selection of Chemical Detection Equipment for Emergency First Responders, Guide 100-06, January 2007, 3rd Edition published by the Department of Homeland Security to assist with this process.
- If still contaminated, repeat shower procedure.
Decontamination of First Responder:
- Begin washing PPE of the first responder using soap and water solution and a soft brush. Always move in a downward motion (from head to toe). Make sure to get into all areas, especially folds in the clothing. Wash and rinse (using cold or warm water) until the contaminant is thoroughly removed.
- Remove PPE by rolling downward (from head to toe) and avoid pulling PPE off over the head. Remove the SCBA after other PPE has been removed.
- Place all PPE in labeled durable 6-mil polyethylene bags.
Decontamination of Infants and Children
- Video: Decontamination of Infants and Children (HHS/AHRQ, Children's Hospital Boston) (Watch video)
- Decontamination of Children (HHS/AHRQ) provides a step-by-step decontamination demonstration in real time, and trains clinicians about the nuances of treating infants and children, who require special attention during decontamination.
Wound Management
References
- Medical Management of Chemical Casualties Handbook, 2nd edition, September, 1995
- Braue EH, Boardman CH. Decontamination of Chemical Casualties
- Jagminas L. CBRNE - Chemical Decontamination (eMedicine)
Treatment Area
Following decontamination the patient should be reassessed; noting changes in triage category (if any), the need for or the modification of supportive therapy (See ABC reminders/Advanced Treatment) .
ABC Reminders
Quickly access airway patency. If trauma is suspected, maintain cervical immobilization manually and apply a cervical collar and a backboard when feasible. Ensure adequate respiration and pulse. Document oxygen saturation. Place on a cardiac monitor.
Link to Primary and Secondary Survey
If the patient is symptomatic, immediately institute emergency life support measures.
Clinical Signs and Symptoms - Link to clinical signs and symptoms
Inhalation Exposure
- The diagnosis of acute chlorine toxicity is primarily clinical, based on symptoms of irritation and breathing difficulty. However, laboratory testing is useful for monitoring the patient and evaluating complications.
- If cough or difficulty in breathing develops, evaluate for hypoxia, respiratory tract irritation, bronchitis, pneumonitis and pulmonary edema. Chest radiography and pulse oximetry (and/or ABG measurements) are recommended if significant inhalation exposure is suspected.
- ECG monitoring should be provided for patients with significant chlorine exposure.
- Inhalation of higher concentrations (>15 ppm) can very rapidly lead to respiratory distress. This can occur almost immediately with initial symptoms of stridor, followed shortly by wheezing, rales, hemoptysis, and subsequent pulmonary edema (including Acute Lung Injury or Acute Respiratory Distress Syndrome). Immediate onset of laryngospasm with respiratory arrest can occur.
- Acute Lung Injury (ALI), Acute Respiratory Distress Syndrome (ARDS)
- ALI/ARDS is a process of nonhydrostatic pulmonary edema with resultant arterial hypoxemia associated with a variety of causative etiologies (including severe chlorine toxicity). Left atrial hypertension should be excluded.
- The standard definition of ALI identifies those patients as having bilateral pulmonary infiltrates and arterial hypoxemia using the concentration of arterial oxygen in the blood divided by the inspired fraction of oxygen (i.e. a PaO2 ratio of less than 300). If the patient's Pa02/Fi02 is less than 200, then a diagnosis of ARDS can be made
- Link to Overview Literature for diagnosis and management of ALI and ARDS
Non-Pharmacologic Treatment
- Administer 100% humidified supplemental oxygen, perform endotracheal intubation and provide assisted ventilation as required.
- Positioning - Improvement in oxygenation has been associated with a change to the prone position.
- Maintain adequate ventilation and oxygenation with frequent monitoring of arterial blood gases, pulse oximetry, and end tidal CO2 monitoring. If a high FIO2 is required to maintain adequate oxygenation, mechanical ventilation and positive-end-expiratory pressure (PEEP) may be required; ventilation with small tidal volumes (6 milliliters/kilogram) and acceptance of permissive hypercarbia is preferred if ARDS develops.
- To minimize barotraumas and other complications, use the lowest amount of Peak airway pressure and PEEP possible while maintaining adequate oxygenation.
- Link - Approaches in the management of acute respiratory failure in children
- Use of smaller tidal volumes (6 milliliters/kilogram) and lower plateau pressures (30 cm water or less) has been associated with decreased mortality and more rapid weaning from mechanical ventilation in patients with ARDS (Brower et al, 2000). Despite the lack of a specific pharmacologic treatment, lung protective ventilation has reduced the mortality of ALI from 40% in 2000 to 25% in 2006.
Drug Therapy for Inhalation Exposure‡*
Animal experiments and anecdotal human experience suggests that inhaled beta-adrenergic agonists, Na bicarbonate therapy, aminophylline, corticosteroids, terbutaline, other beta2 agonists, N-acetyl cysteine and ibuprofen may be effective in treating chlorine-induced pulmonary edema. Optimal doses of these agents have not been established (off label usage)‡*
- Inhaled beta adrenergic agonists if bronchospasm develops - Consider racemic epinephrine aerosol for children who develop stridor. Dose 0.25-0.75 mL of 2.25% racemic epinephrine solution in 2.5 cc water, repeat every 20 minutes as needed, cautioning for myocardial variability. Consider the health of the myocardium before choosing which type of bronchodilator should be administered. Cardiac sensitizing agents may be appropriate; however, the use of cardiac sensitizing agents after exposure to certain chemicals may pose enhanced risk of cardiac arrhythmias (especially in the elderly). Chlorine poisoning is not known to pose additional risk from such drug therapies. The use of bronchial sensitizing agents in situations of multiple chemical exposures may pose additional risks.
- Na Bicarbonate therapy - The utility of nebulized bicarbonate has not been firmly established, and the optimal dose has also not been delineated. A reasonable dose is 3.75-5% nebulized over 20 minutes and may be repeated. A 3.5% solution can be prepared by taking 2 mL of a 7.5% intravenous preparation of sodium bicarbonate solution and combining with 2 mL of normal saline. Because precipitates can form if combined, it is important that nebulized sodium bicarbonate be administered separately from nebulized albuterol sulfate.
- IV Aminophylline is a second line agent that might be helpful - 5-6 milligram/kilogram loading dose followed by 1 milligram/kilogram every 8 to 12 hours to maintain a serum level of 10 to 20 micrograms/milliliter.
- Methylprednisolone - children 2 mg/kg loading then 2 mg/kg divided Q6h, adults 250 mg Q6H, steroids are likely of most utility in patients with latent or overt reactive airway disease.
- Beta2 adrenergic agonists such as terbutaline, isoetharine at conventional doses.
- N-acetylcysteine - up to 10 milliliters of a 20% solution aerosolized.
- Ibuprofen 800 milligrams (15 mg/kg in children) every 8 to 12 hours for at least one dose.
- Antibiotics are indicated only when there is evidence of infection. More than 60% of ARDS patients experience a (nosocomial) pulmonary infection.
Ingestion Exposure
- Induced emesis and gastric lavage are contraindicated to avoid further exposure of the esophagus. Neutralization agents are contraindicated as it is thought an exothermic reaction will occur.
- Blind passage of a NG tube is contraindicated unless cleared by a gastroenterologist
- Lateral neck and chest x-rays should be performed if there is any underlying suspicion of perforation.
- Prior to intubation for esophagoscopy, assessment of laryngotracheal injury should be performed.
- Esophagoscopy (with the possible exception of bleach) should be carried out on all patients with suspected caustic ingestion (at approximately 48 hours post event) to delineate the extent of esophageal injury.
- Bleaches are 5-6% sodium hypochlorite and produce ulceration that usually does not produce strictures or permanent sequelae at these concentrations.
- With bleach exposure, if an oropharyngeal burn is present, esophagoscopy should be performed.
- If no oropharyngeal burn is present, a barium swallow obtained in 3- 6 weeks is adequate.
- At 48 hours post ingestion, enough time has passed such that effects of the injury have demarcated itself so that appropriate grading of severity can be reliably predicted.
- Esophagoscopy allows for the insertion of an NG tube under vision. The NG tube, in addition to providing a mechanism for enteral feedings, assists in maintaining the patency of the esophageal lumen.
- The use of anti-reflux therapy, antibiotics and steroids are the other arms of management.
- The routine use of anti-reflux therapy is recommended to prevent secondary reflux-associated injury (typically proton pump inhibitors for a total of 6 weeks)
- There is evidence suggesting a lower rate of stricture formation with antibiotic usage. However some investigators suggest that antibiotics promote the influx of gram-negative organisms without decreasing stricture formation rates as well as potentially masking serious bacterial infections. A routine antibiotic regime includes the use of third generation cephalosporins for 48 hours, and if oral intake is tolerated, change over to clindamycin for six weeks duration.
- The additive role of steroids is controversial. While multiple studies demonstrate that steroids are able to modify the inflammatory response at the site of injury, multiple trials and reviews have shown little or no measurable benefit from varying doses of steroids in their ability to reduce the rate of stricture formation. Grade 2 injuries are where steroids are felt to be the most beneficial in preventing stricture formation. Many clinicians justify their use when simultaneously treating upper airway edema/laryngeal injury and esophageal injury. One therapeutic approach is to initially utilize dexamethasone for the 48 hours prior to the esophagoscopy, with transition to oral equivalent dosing and continuance of therapy for one more weeks duration.
- In spite of therapy, stricture formation occurs in 10% of esophageal caustic burns. Half of grade two burns have long term strictures.
- The management of esophageal strictures is endoluminal first, and should that fail, then esophageal replacement surgery is utilized.
Fluids
- Crystalloid solutions must be administered cautiously, AVOIDING a net positive fluid balance. Monitor fluid status through a central line or Swan Ganz(R) catheter.
- Diuretics may be needed to avoid a net positive fluid balance but are almost always contraindicated. Pulmonary edema due to chlorine inhalation is not hypervolemic in origin; patients tend to be hypovolemic and hypotensive. Dopamine may be required for treatment of hypotension, bradycardia, or renal failure.
Eye Exposure
- Remove contact lenses and irrigate exposed eyes with copious amounts of room temperature 0.9% saline or water for at least 15 minutes. If irritation, pain, swelling, lacrimation, or photophobia persists after 15 minutes of irrigation, an ophthalmologic examination should be performed.
Dermal Exposure
Frostbite has not been commonly reported but is a potential risk.
- Re-warming
- Do not institute re-warming unless complete re-warming can be assured; re-freezing thawed tissue increases tissue damage. Place affected area in a water bath with a temperature of 40 to 42 degrees Celsius for 15 to 30 minutes until thawing is complete. The bath should be large enough to permit complete immersion of the injured part, avoiding contact with the sides of the bath. A whirlpool bath would be ideal. Some authors suggest that an antibacterial (hexachlorophene or povidone-iodine) be added to the bath water (Murphy et al, 2000).
- Correct systemic hypothermia.
- Re-warming may be associated with increasing pain, requiring narcotic analgesics.
Wound Care
- Digits should be separated by sterile absorbent cotton; no constrictive dressings should be used. Protective dressings should be changed twice per day.
- Perform daily hydrotherapy for 30 to 45 minutes in warm water 40 degrees Celsius. This helps debride devitalized tissue and maintain range of motion.
- The injured extremities should be elevated and should not be allowed to bear weight.
- Prophylactic antibiotics are recommended by some authors.
- Clear blisters should be debrided but hemorrhagic blisters left intact.
- Further surgical debridement should be delayed until mummification demarcation has occurred (60 to 90 days). Spontaneous amputation may occur.
- Analgesics may be required during the re-warming phase; however, patients with severe pain should be evaluated for vasospasm. Arteriography and noninvasive vascular techniques (e.g., Doppler ultrasound, digital plethysmography, isotope scanning), have been useful in evaluating the extent of vasospasm after thawing.
- Tetanus prophylaxis as indicated.
- Topical aloe vera may decrease tissue destruction and should be applied every 6 hours.
- Ibuprofen is a thromboxane inhibitor and may help reduce tissue loss. Adult dose of 200 milligrams every 12 hours is recommended.
- Adjunct pharmacological agents (heparin, vasodilators, prostacyclins, prostaglandin synthetase inhibitors, thrombolytics, and dextran) are controversial and not routinely recommended.
Chronic Symptoms
- After an acute exposure pulmonary function usually returns to baseline in 7 - 14 days. Although a complete recovery usually occurs, prolonged pulmonary impairment may persist. Chlorine exposure can result in a chemical irritant-induced type of asthma (reactive airways dysfunction syndrome - RADS).
‡ Not FDA approved for this indication/Off-label use
* Pregnancy Categories: Refer to DailyMed regarding Pregnancy Categories and additional pregnancy-related information.
Antidotes - there are no specific antidotes for chlorine.
The diagnosis of acute chlorine toxicity is primarily clinical, based on respiratory difficulties and irritation. However, laboratory testing is useful for monitoring the patient and evaluating complications.
Routine laboratory studies include:
- CBC, glucose, and electrolyte determinations
- Massive inhalation may be complicated by hyperchloremic metabolic acidosis; in addition to electrolytes, monitor blood pH.
Disposition and Follow-up
Patient Release
Asymptomatic patients who have normal initial examinations and no signs of toxicity after observation for 48 hours may be discharged with instructions to seek medical care promptly if symptoms develop (see the Chlorine Patient Information Sheet below).
Follow-up
Follow-up is recommended for all hospitalized patients because long-term respiratory problems can result. Respiratory monitoring is recommended until the patient is symptom-free. Chlorine-induced reactive airways dysfunction syndrome (RADS) has been reported to persist from 2 to 12 years.
Follow-up Instructions
![Follow-up instructions in PDF format](chemmimages/pdf.gif)
Adapted from Medical Management Guidelines for Chlorine (ATSDR/CDC)
PDF documents can be viewed with the free Adobe® Reader™
Acute Patient Care Guidelines References
|