Home - Site Map - Videos - Resources - Challenge Game - Contact |
Vaccine Preparation and Disposal |
NCIRD |
|
Vaccines that come as lyophilized (freeze-dried) powders must be mixed with a liquid (called a diluent) in a process known as "reconstitution" before they can be administered.
Diluents vary in their volume. The volume of diluent provided depends on whether a single-dose or multidose vial of vaccine is to be reconstituted. Diluents also vary in their ingredients. Some consist of sterile water only, but others may contain a variety of other substances that can be used to dissolve the lyophilized vaccine into a liquid, stabilize the reconstituted vaccine, and/or maintain the sterility of the reconstituted vaccine. Diluents are specifically designed to meet the volume, pH (acid/alkaline balance), and chemical needs of each vaccine so that optimal immune responses can be achieved. Diluents are not interchangeable, unless specified by the manufacturer (e.g., the diluent for MMR, MMRV, varicella, and zoster vaccine). Therefore, use only the specific diluent provided by the manufacturer for each type of vaccine to ensure adequate potency and safety of the resulting mixture. Do not use diluents from other manufacturers.
Instructions for Reconstitution
Refer to the package inserts for instructions on reconstituting specific vaccines. In general, certain steps should be followed when reconstituting vaccines:
Expiration of Reconstituted Vaccine
Once lyophilized (freeze-dried) vaccines have been reconstituted, their shelf lives are limited and they must be stored under appropriate temperature and light conditions. Reconstituted vaccine must be used within a specified time or else be discarded. Contact the vaccine supplier, which may be the vaccine manufacturer or the state health department immunization program, for specific policies regarding the disposition of expired vaccine. If the expired vaccine is publicly purchased vaccine, contact your state health department immunization program for instructions on returning expired vaccine for excise tax credit.
The life of each reconstituted vaccine varies from product to product. Consult the product package insert for the most up-to-date information about expiration dates and times following reconstitution. Unused reconstituted vaccines kept beyond these limits should not be administered. The best way to avoid such waste is to reconstitute and draw up vaccines immediately before administration.
Mark each opened multidose vial with the date it was first opened. Mark reconstituted vaccine with the date and time it was reconstituted. Dating these vials is important for two reasons. First, some vaccines expire within a certain time after opening or after reconstitution. This may not correspond to the expiration date printed on the vial by the manufacturer. For example, multidose vials of meningococcal vaccine should be discarded if not used within 35 days after reconstitution, even if the expiration date printed on the vial by the manufacturer has not passed. Second, dating opened or reconstituted vials helps manage vaccine inventory by identifying vials that should be used first.
Whenever possible, use all the vaccine in one multidose vial before opening another vial. Similarly, use all the reconstituted vaccine in one vial before reconstituting another vial. This policy helps to reduce vaccine waste.
Use of Multidose Vials Versus Single-Dose Vials
Multidose vaccine vials contain bacteriostatic agents that prevent the growth of bacteria. Once opened, they can be used until their dates of expiration, unless they become contaminated. All multidose vials must be stored under appropriate temperature and light conditions at all times before and after they have been opened. Single-dose vials are meant for one-time use only. Once the protective caps have been removed from single-dose vials, it may not be possible to determine if the rubber seals have been punctured. Therefore, do not open single-dose vials until you are ready to use them. To avoid needless wastage of vaccine, always check the vial before removing the cap to make sure you have the correct vaccine type, and remove the cap only when you are ready to draw up and administer the vaccine. Single-dose vials must be stored under appropriate temperature and light conditions at all times before and after they have been opened. Contact the vaccine supplier, which may be the vaccine manufacturer or the state health department immunization program, for specific policies regarding the disposition of opened unused single-dose vials. If these vials are publicly purchased vaccine, contact the state health department immunization program for instructions on returning opened unused single-dose vials for excise tax credit.
The National Center for Immunization and Respiratory Diseases (NCIRD), Centers for Disease Control and Prevention strongly recommends that providers draw vaccine only at the time of administration to ensure that the cold chain is maintained and that vaccine is not inappropriately exposed to light. Do not predraw doses before they are needed.
Problems Associated with Prefilling Syringes
NCIRD strongly discourages prefilling syringes and has identified the following
The vaccine manufacturers do not recommend that influenza vaccine be predrawn in advance of a large influenza vaccination clinic because there are no data on the stability of vaccine stored in syringes filled by providers. NCIRD also strongly discourages this practice for the reasons noted in the previous section.
Although predrawing vaccine is generally discouraged, a limited amount of vaccine may be predrawn in a mass immunization setting if the following procedures are followed:
Manufacturer-Supplied Prefilled Glass Syringes
Manufacturer-filled glass syringes are available for a variety of vaccines. NCIRD does not have a preference for specific vaccine brands or product presentations; either vials or manufacturer-filled syringes (when available) are acceptable for use, depending on the preferences of your practice. Manufacturer-filled syringes are an alternative to prefilling syringes yourself. These syringes are prepared under sterile conditions that meet standards for proper handling and storage, and they are individually labeled. They have been specially designed by the manufacturers and thoroughly tested to assure vaccine potency and sterility over prolonged storage times. As long as they are stored under appropriate conditions (temperature and light), they may be kept and used until their dates of expiration unless they become contaminated. When manufacturer-filled glass syringes are not supplied with needles, the needles should be attached just before administration. If a needle is attached to a sealed manufacturer prefilled syringe, the syringe should be used or discarded at the end of the clinic day because the sterile seal has been broken. This does not apply to prefilled syringes prepared by the manufacturer with the needle already attached.
Unused vaccine and diluent doses may be returnable under certain circumstances. Contact the vaccine supplier, which may be the vaccine manufacturer or the state immunization program, for specific policies regarding the disposition of unopened vials, expired vials, unused doses, doses drawn but not administered, and potentially compromised vaccine due to inappropriate storage conditions. If these vials or doses are publicly purchased, contact the state health department immunization program for instructions on returning doses for excise tax credit.
The state health department immunization program and the manufacturer may advise you to discard the vials or syringes. This should be done using medical waste disposal procedures. Contact the state health department for details about medical waste disposal procedures in your area. In general, vaccine and diluent vials, used needles, and used syringes (that may or may not contain vaccine) may be dropped into a sharps container and autoclaved, or disposed of following the procedures for all other biohazard materials. In places where medical waste is buried, soaking the medical waste in a 1:10 dilution of bleach for at least 10 minutes before disposal is advised. |
NCIRD |
Centers for Disease Control and Prevention Disclaimer |