Region 4 News Release: 12-188-ATL (052)
Feb. 15, 2012
Contact: Michael D'Aquino Michael Wald
Phone: 404-562-2076 404-562-2078
Email: d'aquino.michael@dol.gov wald.michael@dol.gov
Publix Supermarkets cited by US Department of Labor's OSHA for willful
and repeat violations following amputation of employee's hand
Penalties proposed total $182,000
JACKSONVILLE, Fla. – Publix Supermarkets Inc. has been cited by the U.S. Department of Labor's Occupational Safety and Health Administration for 16 safety and health violations at its 9786 W. Beaver St. distribution facility in Jacksonville after receiving a complaint in September that a worker's hand was amputated while cleaning conveyor equipment. Proposed penalties total $182,000.
One willful violation with a $70,000 penalty was cited for failing to utilize procedures for the control of potentially hazardous energy when employees service or clean equipment. A willful violation is one committed with intentional knowing or voluntary disregard for the law's requirements, or with plain indifference to worker safety and health.
Two repeat violations with penalties of $66,000 include failing to develop, document and utilize lockout/tagout procedures and not conducting an annual inspection of the energy control procedures. A repeat violation exists when an employer previously has been cited for the same or a similar violation of a standard, regulation, rule or order at any facility in federal enforcement states within the last five years. The company's Dacula, Ga., location was cited for the same violation in April 2008.
Publix Supermarkets also has been cited for six serious violations with penalties of $39,400 for failing to adequately train employees in procedures for the lockout/tagout of machine energy sources, install machine guarding on equipment where employees could come into contact with rotating and ingoing nip points, protect workers from struck by hazards by not anchoring equipment to the floor, protect workers from electric shock by having damaged electrical equipment repaired, use appropriate electrical outlet boxes in wet/damp locations and use receptacles that did not have weatherproof enclosures. A serious violation occurs when there is substantial probability that death or serious physical harm could result from a hazard about which the employer knew or should have known.
Six other-than-serious safety violations with penalties of $6,600 have been cited for failing to complete an OSHA 301 log injury and illness incident report or its equivalent for 2007, 2008, 2009 and 2010, and have a company executive sign the OSHA 300 log of injuries and illnesses for 2007 and 2008. One other-than-serious health violation, with no monetary penalty, has been cited for failing to have a written hazard communications program that listed hazardous chemicals in the workplace. An other-than-serious violation is one that has a direct relationship to job safety and health, but probably would not cause death or serious physical harm.
"Publix is well aware of the hazards the cleaning crew was exposed to, yet took no steps to safeguard employees by controlling the conveyor equipment's energy source,” said Brian Sturtecky, OSHA's area director in Jacksonville. "Exposing workers to amputation hazards is unacceptable, and corrective action must be taken immediately.”
Due to the repeat violations and the nature of the hazards, OSHA has placed Publix in its Severe Violator Enforcement Program, which mandates targeted follow-up inspections to ensure compliance with the law. The program focuses on recalcitrant employers that endanger workers by committing willful, repeat or failure-to-abate violations. For more information on the program, visit http://s.dol.gov/J3.
Publix is a privately owed company with 1,026 supermarkets, eight distribution centers and five manufacturing facilities with operations in Florida, Georgia, South Carolina, Alabama and Tennessee. The Jacksonville distribution center employs approximately 450 workers and has a small fresh foods manufacturing process area.
The citations can be viewed at http://www.osha.gov/ooc/citations/PublixSupermarkets_315479907_0213_12.pdf.*
The company has 15 business days from receipt of the citations and proposed penalties to comply, request a conference with OSHA's area director or contest the findings before the independent Occupational Safety and Health Review Commission.
To ask questions, obtain compliance assistance, file a complaint, or report workplace hospitalizations, fatalities or situations posing imminent danger to workers, the public should call OSHA's toll-free hotline at 800-321-OSHA (6742) or the agency's Jacksonville Area Office at 904-232-2895.
Under the Occupational Safety and Health Act of 1970, employers are responsible for providing safe and healthful workplaces for their employees. OSHA's role is to ensure these conditions for America's working men and women by setting and enforcing standards, and providing training, education and assistance. For more information, visit http://www.osha,gov.
###
U.S. Department of Labor news materials are accessible at http://www.dol.gov. The information above is available in large print, Braille, audio tape or disc from the COAST office upon request by calling 202-693-7828 or TTY 202-693-7755.
* Accessibility Assistance Contact OSHA's Office of Communications at 202-693-1999 for assistance accessing PDF materials.
|