![USDA Logo](https://webarchive.library.unt.edu/eot2008/20090305045926im_/http://www.fas.usda.gov/pecad2/images/blue_fas_logo.jpg) |
Production
Estimates and Crop Assessment Division
Foreign Agricultural Service |
June 16, 2004
Sunflowerseed Production in Ukraine and Russia
The USDA estimates 2004/05 Russian
sunflowerseed production at 4.2 million tons, against a record 4.85 million last
year. Harvested area is estimated at
4.2 million hectares, down 13 percent from last year.
Sunflowers were planted on a reported 4.5 million hectares; in a typical
year, only 90 to 92 percent of sown area is harvested. The
year-to-year reduction in area is attributed to intense competition from grains,
as reported by the U.S. agricultural attache, and relatively low winterkill,
which resulted in less reseeding with spring crops compared to last year. For Ukraine, 2004/05 sunflower area is estimated at 3.2 million hectares and production
at 3.5 million tons, down 16 and 18 percent, respectively, from last year’s
record levels. Cool weather in Ukraine
during late May likely hampered early development of earlier-planted
sunflowers, but is unlikely result in
significant yield reduction. Soil-moisture
conditions are generally favorable throughout the main sunflower regions in
Ukraine and Russia.
In 2003/04, sunflower area increased by 28 percent in Russia
and 40 percent in Ukraine. The chief reason for the huge
year-to-year jump was unusually high losses of winter wheat due to severe winter
weather, and the subsequent replanting of these damaged fields with
spring-planted crops, including barley, sunflowers, and corn.
Russia’s top four winter wheat producing oblasts –
Rostov,
Krasnodar, Volgograd, and Saratov
– are also the country’s top sunflowerseed oblasts.
The combined winter wheat losses in these oblasts totaled 1.6 million
hectares, or 34 percent of the sown area, and farmers responded by increasing
sunflower area by nearly 700,000 hectares from the previous year.
In Ukraine, meanwhile, a staggering 69 percent of 2003/04 winter grains were destroyed by
a combination of December frosts and persistent ice crusting during February and
March. Because April 2003 was
unusually cool, many farmers decided not to risk reseeding with spring barley,
fearing that the late planting would reduce yield potential, and instead chose
corn and sunflowers; planted corn area for 2003/04 increased by 800,000 hectares from
the previous year, and sunflower area by nearly one million hectares. As
in
Russia, the highest year-to-year increases in sunflower area were recorded in the
oblasts with the highest winterkill.
Because of a combination of high price and low cost of production
relative to wheat (with the lower cost of production based in part on less
application of fertilizer and chemicals), sunflowers
have become one of the most consistently profitable crops.
In recent years, farmers’ planting decisions have become largely
market-based, and the profitability of sunflowerseed has fueled a significant
expansion in planted area. Smaller,
private farms especially have restructured their crop selections and are growing
the most profitable crops like wheat and sunflowerseed.
Even considering the increase in wheat prices relative to sunflowerseed
– resulting from the disastrous 2003 wheat harvest and the second consecutive
bumper harvest of sunflowerseed – farmers in Ukraine still consistently cite
sunflowerseed as the most profitable crop in the rotation.
The popularity of sunflowerseed stems also from the fact
that demand for the crop has traditionally been high.
Five years ago in Ukraine, for example, crushing plants were operating at only 75 percent of capacity and
operators were desperately trying to increase procurements of seed for
processing. In response, the
government imposed a controversial 17-percent export duty in an effort to reduce
sunflowerseed exports and support the domestic vegetable-oil industry.
Since then, crushing capacity in
Ukraine
has increased by 25 percent, to over 3 million tons, and is slated to increase
further with the planned construction of a 600,000-ton facility in the port city
of Ilichevsk.
Oilseed demand is strong in Russia
as well. The U.S.agricultural attaché in Moscow
reports that current oilseed-crushing capacity in Russia
stands at 4.8 million tons and plants operate at full capacity throughout the
year. And – according to veteran
commodity analysts in Moscow
– crushing capacity is slated to increase.
Given the forecast expansion in capacity, and the need for a steady and
stable supply of oilseed that the new plants will generate, demand for
sunflowerseed seems unlikely to diminish in the near future.
Over the past six years, sunflower area averaged 4.5
million hectares in Russia and 2.8 million in Ukraine. During the previous six years
(1992 through 1997, the first six years following independence), area averaged
3.4 million and 1.8 million, respectively. In
order to achieve area increases of 30 percent in Russia and over 50 percent in
Ukraine, many farmers have abandoned the crop-rotation practices traditionally
recommended by agricultural officials, which called for planting sunflowers no
more than once every seven years in the same field.
The 1-in-7 rotation is based on three factors:
·
Prevention of disease, especially soil-borne fungal diseases.
With most farms facing financial constraints that limit their access to
fungicides and disease-resistant hybrids, specialists see crop rotation as the
best way – or the only way – to control disease in sunflower fields.
·
Depletion of soil fertility. Because
of their deep rooting system, sunflowers reportedly extract higher amounts of
nutrients from the soil than do other crops in the rotation.
·
Depletion of soil moisture. Most
of the prime sunflower-growing regions in Russiaand Ukraine
are located in the so-called zones of risky agriculture, where drought is a
constant threat. Sunflowers
reportedly extract higher amounts of soil moisture than other crops (because of
those deep roots) and specialists maintain that their frequency in the rotation
should be limited, and that they occupy last place in the rotation prior to the
fallow year, in order to replenish soil moisture reserves.
Prior to the spring planting campaign, Ukraine
agricultural officials unsuccessfully urged farmers to scale back sunflower
area to 2.5 million hectares, based on Ministry of Agriculture recommendations
that sunflower area not exceed 8 percent of the country’s total cultivated
area. But because of the high demand
for sunflowerseed, and the crop’s value as an export commodity, farmers are
determined to plant sunflowers and specialists’ recommendations have become
largely irrelevant. In fact, the
experience of farmers and the observations of commodity analysts suggest that
the traditional 1-in-7 rotation may be too conservative and that farmers in most
regions can safely plant sunflowers once every four years – with proper
management – with no detrimental effect on yield.
(Considering the steady reduction in cultivated area in Russia, from
roughly 118 million hectares in 1990 to 85 million in 2003, it would be conceivable for farmers to maintain
high sunflower area within1 conventional crop-rotation constraints by expanding
sunflower planting into fields that haven’t been tilled for years.
The initial expense of reclaiming idle fields, however, could be
prohibitive. Furthermore, a
considerable portion of the area contraction occurred on marginal land with
inherently lower productivity.)
Following the breakup of the Soviet Union
in 1991, sunflowerseed yields dropped due to a sudden and sharp reduction of heavy State
subsidies for agriculture and a 90-percent reduction in fertilizer application
rates. Yields stabilized by the
mid-1990’s, however, and during the period of steady sunflower area expansion of the
past ten years yields have exhibited no downward trend in either Russia or
Ukraine, despite financial constraints that have restricted farmers’ use of
fertilizer and plant-protection chemicals. Indeed, prospects for an increase in sunflowerseed yields could be considered
favorable, with producers likely to benefit from the interest of traders and
crushers to ensure a supply of product for export and processing.
Although many large agricultural “holding companies” have become
disappointed in their agricultural investments and are retreating from
involvement in agriculture, the exception has been companies involved in oilseed
production and processing. Companies
that have invested large amounts of money in the construction of new crushing
plants and the modernization of old facilities are keen to maintain a steady
supply of raw materials.
The long-term yield impact, if any, of increased frequency
of sunflowers in the crop rotation is difficult to determine since the explosive
growth in sunflower area began only five to ten years ago.
The key to maintaining high area and boosting yield lies chiefly, and not
surprisingly, in financing. Disease
problems can be addressed by the use of resistant varieties, prohibitively
expensive for most farmers, and soil fertility problems with application of
mineral fertilizer. The moisture
problem could be more difficult to overcome, although some farmers -- even in the zones of risky
agriculture -- are already “pushing the rotation,” planting up to three
consecutive years with, according to them, no deterioration in yield.
For
more information, contact Mark Lindeman
with the Production Estimates and Crop Assessment Division, at (202)
690-0143
![PECAD logo, with links](https://webarchive.library.unt.edu/eot2008/20090305045926im_/http://www.fas.usda.gov/pecad2/images/PECAD_earth.jpg) |
Updated:
September 05, 2003
|
Write us:
Pecadinfo@fas.usda.gov |
Index | | FAS
Home | USDA | |