[Code of Federal Regulations]
[Title 40, Volume 9]
[Revised as of January 1, 2007]
From the U.S. Government Printing Office via GPO Access
[CITE: 40CFR63.550]

[Page 707-708]
 
                   TITLE 40--PROTECTION OF ENVIRONMENT
 
         CHAPTER I--ENVIRONMENTAL PROTECTION AGENCY (CONTINUED)
 
PART 63_NATIONAL EMISSION STANDARDS FOR HAZARDOUS AIR POLLUTANTS
 
Subpart X_National Emission Standards for Hazardous Air Pollutants from 
                         Secondary Lead Smelting
 
Sec.  63.550  Recordkeeping and reporting requirements.

    (a) The owner or operator of a secondary lead smelter shall comply 
with all of the recordkeeping requirements under Sec.  63.10 of the 
General Provisions. In addition, each owner or operator of a secondary 
lead smelter shall maintain for a period of 5 years, records of the 
information listed in paragraphs (a)(1) through (a)(6) of this section.
    (1) An identification of the date and time of all bag leak detection 
system

[[Page 708]]

alarms, their cause, and an explanation of the corrective actions taken.
    (2) If an owner or operator chooses to demonstrate continuous 
compliance with the total hydrocarbon emission standards under Sec.  
63.543 (c), (d), or (e) by employing the method allowed in Sec.  
63.548(j)(1), the records shall include the output from the continuous 
temperature monitor, an identification of periods when the 3-hour 
average temperature fell below the minimum established under Sec.  
63.548(j)(1), and an explanation of the corrective actions taken.
    (3) If an owner or operator chooses to demonstrate continuous 
compliance with the total hydrocarbon emission standard under Sec.  
63.543 (c), (d), or (e) by employing the method allowed in Sec.  
63.548(j)(2), the records shall include the output from the total 
hydrocarbon continuous monitoring system, an identification of the 
periods when the 3-hour average total hydrocarbon concentration exceeded 
the applicable standard and an explanation of the corrective actions 
taken.
    (4) Any recordkeeping required as part of the practices described in 
the standard operating procedures manual required under Sec.  63.545(a) 
for the control of fugitive dust emissions.
    (5) Any recordkeeping required as part of the practices described in 
the standard operating procedures manual for baghouses required under 
Sec.  63.548(a).
    (6) Records of the pressure drop and water flow rate for wet 
scrubbers used to control metal hazardous air pollutant emissions from 
process fugitive sources.
    (b) The owner or operator of a secondary lead smelter shall comply 
with all of the reporting requirements under Sec.  63.10 of the General 
Provisions. The submittal of reports shall be no less frequent than 
specified under Sec.  63.10(e)(3) of the General Provisions. Once a 
source reports a violation of the standard or excess emissions, the 
source shall follow the reporting format required under Sec.  
63.10(e)(3) until a request to reduce reporting frequency is approved.
    (c) In addition to the information required under Sec.  63.10 of the 
General Provisions, reports required under paragraph (b) of this section 
shall include the information specified in paragraphs (c)(1) through 
(c)(6) of this section.
    (1) The reports shall include records of all alarms from the bag 
leak detection system specified in Sec.  63.548(e).
    (2) The reports shall include a description of the procedures taken 
following each bag leak detection system alarm pursuant to Sec.  
63.548(f) (1) and (2).
    (3) The reports shall include the information specified in either 
paragraph (c)(3)(i) or (c)(3)(ii) of this section, consistent with the 
monitoring option selected under Sec.  63.548(h).
    (i) A record of the temperature monitor output, in 3-hour block 
averages, for those periods when the temperature monitored pursuant to 
Sec.  63.548(j)(1) fell below the level established in Sec.  
63.548(j)(1).
    (ii) A record of the total hydrocarbon concentration, in 3-hour 
block averages, for those periods when the total hydrocarbon 
concentration being monitored pursuant to Sec.  63.548(j)(2) exceeds the 
relevant limits established in Sec.  63.543 (c), (d), and (e).
    (4) The reports shall contain a summary of the records maintained as 
part of the practices described in the standard operating procedures 
manual for baghouses required under Sec.  63.548(a), including an 
explanation of the periods when the procedures were not followed and the 
corrective actions taken.
    (5) The reports shall contain an identification of the periods when 
the pressure drop and water flow rate of wet scrubbers used to control 
process fugitive sources dropped below the levels established in Sec.  
63.548(i), and an explanation of the corrective actions taken.
    (6) The reports shall contain a summary of the fugitive dust control 
measures performed during the required reporting period, including an 
explanation of the periods when the procedures outlined in the standard 
operating procedures manual pursuant to Sec.  63.545(a) were not 
followed and the corrective actions taken. The reports shall not contain 
copies of the daily records required to demonstrate compliance with the 
requirements of the standard operating procedures manuals required under 
Sec. Sec.  63.545(a) and 63.548(a).

[[Page 709]]