Benzene

71-43-2

Hazard Summary-Created in April 1992; Revised in January 2000

Benzene is found in the air from emissions from burning coal and oil, gasoline service stations, and motor vehicle exhaust. Acute (short-term) inhalation exposure of humans to benzene may cause drowsiness, dizziness, headaches, as well as eye, skin, and respiratory tract irritation, and, at high levels, unconsciousness. Chronic (long-term) inhalation exposure has caused various disorders in the blood, including reduced numbers of red blood cells and aplastic anemia, in occupational settings. Reproductive effects have been reported for women exposed by inhalation to high levels, and adverse effects on the developing fetus have been observed in animal tests. Increased incidence of leukemia (cancer of the tissues that form white blood cells) have been observed in humans occupationally exposed to benzene. EPA has classified benzene as a Group A, human carcinogen.

Please Note: The main sources of information for this fact sheet are the Agency for Toxic Substances and Disease Registry's (ATSDR's) Toxicological Profile for Benzene and EPA's Integrated Risk Information System (IRIS), which contains information on the carcinogenic effects of benzene including the unit cancer risk for inhalation exposure.

Uses

Benzene is used as a constituent in motor fuels; as a solvent for fats, waxes, resins, oils, inks, paints, plastics, and rubber; in the extraction of oils from seeds and nuts; and in photogravure printing. It is also used as a chemical intermediate. Benzene is also used in the manufacture of detergents, explosives, pharmaceuticals, and dyestuffs. (2,6)

Sources and Potential Exposure

Individuals employed in industries that manufacture or use benzene may be exposed to the highest levels of benzene. (1)
Benzene is found in emissions from burning coal and oil, motor vehicle exhaust, and evaporation from gasoline service stations and in industrial solvents. These sources contribute to elevated levels of benzene in the ambient air, which may subsequently be breathed by the public. (1)
Tobacco smoke contains benzene and accounts for nearly half the national exposure to benzene. (1)
Individuals may also be exposed to benzene by consuming contaminated water. (1)

Assessing Personal Exposure

Measurement of benzene in an individual's breath or blood or the measurement of breakdown products in the urine (phenol) can estimate personal exposure. However, the tests must be done shortly after exposure and are not helpful for measuring low levels of benzene. (1)

Health Hazard Information

Acute Effects:

Coexposure to benzene with ethanol (e.g., alcoholic beverages) can increase benzene toxicity in humans. (1)
Neurological symptoms of inhalation exposure to benzene include drowsiness, dizziness, headaches, and unconsciousness in humans. Ingestion of large amounts of benzene may result in vomiting, dizziness, and convulsions in humans. (1)
Exposure to liquid and vapor may irritate the skin, eyes, and upper respiratory tract in humans. Redness and blisters may result from dermal exposure to benzene. (1,2)
Animal studies show neurologic, immunologic, and hematologic effects from inhalation and oral exposure to benzene. (1)
Tests involving acute exposure of rats, mice, rabbits, and guinea pigs have demonstrated benzene to have low acute toxicity from inhalation, moderate acute toxicity from ingestion, and low or moderate acute toxicity from dermal exposure. (3)

Chronic Effects (Noncancer):

Chronic inhalation of certain levels of benzene causes disorders in the blood in humans. Benzene specifically affects bone marrow (the tissues that produce blood cells). Aplastic anemia,⁽¹⁾ excessive bleeding, and damage to the immune system (by changes in blood levels of antibodies and loss of white blood cells) may develop. (1)
In animals, chronic inhalation and oral exposure to benzene produces the same effects as seen in humans. (1)
Benzene causes both structural and numerical chromosomal aberrations in humans. (1)
EPA has not established a Reference Concentration (RfC) or a Reference Dose (RfD) for benzene. (4)
The California Environmental Protection Agency (CalEPA) has established a chronic reference exposure level of 0.06 milligrams per cubic meter (0.06 mg/m³) for benzene based on hematological effects in humans. The CalEPA reference exposure level is a concentration at or below which adverse health effects are not likely to occur. It is not a direct estimator of risk, but rather a reference point to gauge the potential effects. At lifetime exposures increasingly greater than the reference exposure level, the potential for adverse health effects increases. (5)
ATSDR has established an acute inhalation minimal risk level (MRL) of 0.2 mg/m³ (0.05 parts per million [ppm]) based on immunological effects in mice and an intermediate MRL of 0.01 mg/m³ (0.004 ppm) based on neurological effects in mice. The MRL is an estimate of the daily human exposure to a hazardous substance that is likely to be without appreciable risk of adverse noncancer health effects over a specified duration of exposure. (1)

Reproductive/Developmental Effects:

Several occupational studies suggest that benzene may impair fertility in women exposed to high levels. However, these studies are limited due to lack of exposure history, simultaneous exposure to other substances, and lack of followup. (1)
Available human data on the developmental effects of benzene are inconclusive due to concomitant exposure to other chemicals, inadequate sample size, and lack of quantitative exposure data. (1)
Adverse effects on the fetus, including low birth weight, delayed bone formation, and bone marrow damage, have been observed where pregnant animals were exposed to benzene by inhalation. (1)

Cancer Risk:

Increased incidence of leukemia (cancer of the tissues that form white blood cells) has been observed in humans occupationally exposed to benzene. (1,4)
EPA has classified benzene as a Group A, known human carcinogen. (4)
EPA uses mathematical models, based on human and animal studies, to estimate the probability of a person developing cancer from breathing air containing a specified concentration of a chemical. EPA calculated a range of 2.2 x 10^-6 to 7.8 x 10^-6 as the increase in the lifetime risk of an individual who is continuously exposed to 1 µg/m³ of benzene in the air over their lifetime. EPA estimates that, if an individual were to continuously breathe air containing benzene at an average of 0.13 to 0.45 µg/m³ (1.3 x 10^-4 to 4.5 x 10^-4 mg/m³) over his or her entire lifetime, that person would theoretically have no more than a one-in-a-million increased chance of developing cancer as a direct result of continuously breathing air containing this chemical. Similarly, EPA estimates that continuously breathing air containing 1.3 to 4.5 µg/m³ (1.3 x 10^-3 to 4.5 x 10^-3 mg/m³) would result in not greater than a one-in-a-hundred thousand increased chance of developing cancer, and air containing 13 to 45 µg/m³ (1.3 x 10^-2 to 4.5 x 10^-2 mg/m³) would result in not greater than a one-in-ten thousand increased chance of developing cancer. For a detailed discussion of confidence in the potency estimates, please see IRIS. (4)
EPA has calculated an oral cancer slope factor ranging from 1.5 x 10^-2 to 5.5 x 10^-2 (mg/kg/d)^-1and is an extrapolation from inhalation dose-response data. (4)

Physical Properties

The chemical formula for benzene is C₆H₆, and it has a molecular weight of 78.11 g/mol. (4)
Benzene occurs as a volatile, colorless, highly flammable liquid that dissolves easily in water. (1,7)
Benzene has a sweet odor with an ASTDR reported odor threshold of 1.5 ppm (5 mg/m³).
The vapor pressure for benzene is 95.2 mm Hg at 25 °C, and it has a log octanol/water partition coefficient (log K_ow) of 2.13. (1)

Conversion Factors (only for the gaseous form):
To convert concentrations in air (at 25°C) from ppm to mg/m³: mg/m³ = (ppm) × (molecular weight of the compound)/(24.45). For benzene: 1 ppm = 3.19 mg/m³. To convert concentrations in air from µg/m³ to mg/m³: mg/m³ = (µg/m³) × (1 mg/1,000 µg).

Health Data from Inhalation Exposure

ACGIH STEL--American Conference of Governmental and Industrial Hygienists' short-term exposure limit.
ACGIH TLV--American Conference of Governmental and Industrial Hygienists' threshold limit value expressed as a time-weighted average; the concentration of a substance to which most workers can be exposed without adverse effects.
AIHA ERPG--American Industrial Hygiene Association's emergency response planning guidelines. ERPG 1 is the maximum airborne concentration below which it is believed nearly all individuals could be exposed up to one hour without experiencing other than mild transient adverse health effects or perceiving a clearly defined objectionable odor; ERPG 2 is the maximum airborne concentration below which it is believed nearly all individuals could be exposed up to one hour without experiencing or developing irreversible or other serious health effects that could impair their abilities to take protective action. The American Industrial Hygiene Association's detection and recognition odor thresholds for benzene are 61 ppm and 97 ppm, respectively.
LC₅₀ (Lethal Concentration₅₀)--A calculated concentration of a chemical in air to which exposure for a specific length of time is expected to cause death in 50% of a defined experimental animal population.
NIOSH REL--National Institute of Occupational Safety and Health's recommended exposure limit; NIOSH-recommended exposure limit for an 8- or 10-h time-weighted-average exposure and/or ceiling.
NIOSH STEL--NIOSH's short term exposure limit; NIOSH recommended exposure limit for a 15-minute period.
OSHA PEL--Occupational Safety and Health Administration's permissible exposure limit expressed as a time-weighted average; the concentration of a substance to which most workers can be exposed without adverse effect averaged over a normal 8-h workday or a 40-h workweek.
OSHA STEL--Occupational Safety and Health Administration's short-term exposure limit.

The health and regulatory values cited in this graph were obtained in December 1999.
^aHealth numbers are toxicological numbers from animal testing or risk assessment values developed by EPA.
^bRegulatory numbers are values that have been incorporated in Government regulations, while advisory numbers are nonregulatory values provided by the Government or other groups as advice. OSHA numbers are regulatory, whereas NIOSH, ACGIH, and AIHA numbers are advisory.
^c The NOAEL is from the critical study used as the basis for the CalEPA chronic reference exposure level.

References

Agency for Toxic Substances and Disease Registry (ATSDR). Toxicological Profile for Benzene (Draft). U.S. Public Health Service, U.S. Department of Health and Human Services, Atlanta, GA. 1997.
M. Sittig. Handbook of Toxic and Hazardous Chemicals and Carcinogens. 2nd ed. Noyes Publications, Park Ridge, NJ. 1985.
U.S. Department of Health and Human Services. Registry of Toxic Effects of Chemical Substances (RTECS, online database). National Toxicology Information Program, National Library of Medicine, Bethesda, MD. 1993.
U.S. Environmental Protection Agency. Integrated Risk Information System (IRIS) on Benzene. National Center for Environmental Assessment, Office of Research and Development, Washington, DC. 2002.
California Environmental Protection Agency (CalEPA). Air Toxics Hot Spots Program Risk Assessment Guidelines: Part III. Technical Support Document for the Determination of Noncancer Chronic Reference Exposure Levels. SRP Draft. Office of Environmental Health Hazard Assessment, Berkeley, CA. 1999.
The Merck Index. An Encyclopedia of Chemicals, Drugs, and Biologicals. 11th ed. Ed. S. Budavari. Merck and Co. Inc., Rahway, NJ. 1989.
American Conference of Governmental Industrial Hygienists (ACGIH). 1999 TLVs and BEIs. Threshold Limit Values for Chemical Substances and Physical Agents. Biological Exposure Indices. Cincinnati, OH. 1999.
Occupational Safety and Health Administration (OSHA). Occupational Safety and Health Standards, Toxic and Hazardous Substances. Code of Federal Regulations. 29 CFR 1910.1000. 1998.
National Institute for Occupational Safety and Health (NIOSH). Pocket Guide to Chemical Hazards. U.S. Department of Health and Human Services, Public Health Service, Centers for Disease Control and Prevention. Cincinnati, OH. 1997.

1. *Aplastic anemia is a risk factor for developing acute nonlymphocytic leukemia.