Portable Ladders Training Guide
(Taken from the "Tailgate Meetings that Work : A Guide to Effective Construction Safety Training" series)  PDF Version
LOHP Logo

Versión en español

Robin Baker, Robert Downey, Mary Ruth Gross, Charles Reiter
Labor Occupational Health Program (LOHP) School of Public Health, University of California, Berkeley Ca.

These tailgate/toolbox talks were developed for use under California OSHA regulations. The complete set is available from the Labor Occupational Health Program at UC Berkeley. For ordering information, visit the website (www.lohp.org) The American Conference of Government Industrial Hygienists (ACGIH) has adapted these talks to apply to federal OSHA regulations. To contact ACGIH, visit its web site (www.acgih.org).
    Before you begin the meeting...

  • Does this topic relate to the work the crew is doing? If not, choose another topic.
  • Did you read this Training Guide and fill in the blanks where thePencil Icon appears? (To find the information you need, look over the Safety Walkaround Checklist for this topic.)
  • Did you bring a portable ladder so you can show the crew how to inspect it?
Begin: Did you know that even a six-foot fall from a ladder can kill you? More often, you might break an arm or leg. When you fall off a ladder on a construction site, you can land on almost anything, so internal injuries are common.

Falls from ladders happen because you slip or because the ladder slips. If you're in a hurry, there's more chance of falling. Take the time to use the right ladder the right way.

You or a crew member may want to add a personal story about portable ladders.

Explain: The main topic today will be portable ladders. They may be either metal or wood. On many construction sites there are also fixed ladders. The safety rules for fixed ladders are a little different, and we won't cover them today.

Next, discuss with the crew what types of portable ladders will be used at this particular job site, and where:

Pencil Icon

____________________________________________________

____________________________________________________


ASK THE CREW THESE QUESTIONS:

After each question, give the crew time to suggest possible answers. Use the information following each question to add points that no one mentions.

1. More than half of all ladder accidents happen because the ladder slips. What are some ways to keep a ladder from slipping?

  • Place the ladder on a firm, level surface that isn't slippery.
  • Use a ladder with safety feet, especially if you're setting it on a smooth floor.
  • Always secure portable ladders. Nail it to a permanent structure, tie off, or block them.
  • Make sure the ladder's supports (feet and upper risers) are free of grease and mud.
  • Make sure the ladder is leaning against something secure (not a gutter, window sash, window pane, or anything that can move).
  • If the ladder is leaning against a smooth surface, have wall grips on the risers to prevent side slipping.
  • Make sure the ladder is leaning against something secure (not a gutter, window sash, window pane, or anything that can move).
  • Don't set a ladder on top of boxes or other movable objects.
  • Never use a ladder in high winds.
  • Barricade a ladder if it's in an area where it could get bumped. For example, don't use a ladder in front of a door that might open, unless there is a barricade or guard.

2. What's the correct angle for a ladder?

  • Set it one foot out from the wall for every four feet of ladder length (75° pitch).

3. Nearly a third of all ladder accidents happen because a person slips. What are some things you can do to keep yourself from slipping?

  • Use a ladder with non-skid treads (or a nonskid coating) on the rungs.
  • Make sure the rungs are free of mud, grease, and other slippery material.
  • Make sure your shoes are free of mud and grease.
  • When you're on a ladder, don't lean too far out -- never beyond arm's length.
  • When going up or down a ladder, always face the ladder and use both hands.
  • Don't try to adjust an extension ladder when you're standing on a surface above it.
  • Don't stand or work on the top three rungs of a straight ladder unless you're tied off. At the top, there's nothing to grip.
  • Don't step on any rung above a ladder's upper support. It may cause the bottom of the ladder to kick out.
  • Don't stand or work at the top (cap) of a stepladder.
  • If you use a stepladder, make sure it's fully open and locked.

4. How should you carry tools or materials up or down a ladder?

  • Use a tool belt to keep your hands free.
  • Pull equipment and materials up with a line.

5. To make sure your ladder is in good repair, you should inspect it before and after each job. When you inspect a ladder, what should you look for?

Using the portable ladder you brought to the meeting, demonstrate the points below.

  • All rungs are connected securely to the side rails.
  • No rungs or side rails are missing, loose, broken, cracked, or corroded.
  • No nails, screws, or rivets are sheared off or missing.

6. What if a ladder is defective?

  • If you notice an unsafe ladder don't use it. Report it right away.
  • Defective ladders should be removed from service and tagged.

7. What are some things to keep in mind when you're choosing a ladder for a specific job?

  • Use a ladder that is safety-approved. Look for a label showing that it meets American National Standards Institute (ANSI) safety requirements.
  • Use a ladder of the right length. The side rails should extend at least three feet, but not more than four feet, above the ladder's upper support.
  • Use a ladder that's strong enough to support you.
  • Never splice two ladders together.
  • Don't let more than one person at a time on a ladder unless you're using a ladder that's specially designed for that purpose.
  • Don't use a metal ladder near live electrical parts or within six feet of high voltage electrical lines. (Increase the distance for very high voltage). Remember that electricity can arc. Portable metal ladders should have a warning label on them to remind you.
  • Don't use a ladder for anything but its intended purpose. For example, don't use it as a brace or skid. Don't use it horizontally as a walkway or scaffold.

CAL/OSHA REGULATIONS

Explain: Most of the safety measures we've talked about are required by Cal/OSHA. We have to take these precautions—it's the law. I have a Checklist of the Cal/OSHA regulations on portable ladders. If you'd like to know more, see me after the meeting.

COMPANY RULES

(Only if applicable.) Besides the Cal/OSHA regulations, we have some additional company rules about portable ladders.

Pencil Icon

Discuss company rules: __________________________________________________

 

COMMENTS FROM THE CREW

Ask: Do you have any other concerns about portable ladders? Do you see any problems on our job? (Let the steward answer first, if there is one.)

What about other jobs you've worked on? Have you had any experience with portable ladders that might help us work safer on this job?

Sign Off Form
PORTABLE LADDERS

Date Prepared:_________________________ By:_______________________
Project Name/No.______________________ Location:__________________
NAMES OF THOSE WHO ATTENDED THIS SAFETY MEETING
Printed Name
Signature
   
   
   
   
   
   
   
   
   
   
   
   
   
   
   
   
   
   
   
   
   
   
   
   

Tailgate Meetings That Work : Collection



Published in June, 1994 by: Labor Occupational Health Program, School of Public Health, 2515 Channing Way, University of California, Berkeley, CA 94720. Phone: (510) 642-5507.

Permission is granted to duplicate these materials for non-profit educational purposes, provided that copies are not offered for sale.


This paper appears in the eLCOSH website with the permission of the author and/or copyright holder and may not be reproduced without their consent. eLCOSH is an information clearinghouse. eLCOSH and its sponsors are not responsible for the accuracy of information provided on this web site, nor for its use or misuse.


 eLCOSH | CDC | NIOSH | Site Map | Search | Links | Help | Contact Us | Privacy Policy
Other Job Site Trade Hazard Site Map Search Spanish Items Help Links Contact eLCOSH Non-English Materials Training Materials NIOSH Home CDC Home eLCOSH Home