ACCSH 1988-1, exh 1, Fatality/Catastrophe Investigation Final Report
|
|
OSHA Advisory Committee for Construction Safety and Health
eLCOSH Editor's note:
The OSHA Advisory Committee for Construction Safety and Health (ACCSH) was authorized in the
1969 Construction Safety Act (US Code Title 40§3704, to advise OSHA on matters related to construction safety and health. It consists of five
public representatives (one is normally from a State OSHA program, one from NIOSH, etc.), five labor representatives
(normally from various Building Trades Unions) and five management representatives (primarily from contractor trade associations).
The ACCSH often sets up work groups, which are open to the public, to draft positions on various topics or issues. These
positions are then often voted on by the full ACCSH and those recommendations referred to OSHA for their consideration.
These work products represent a lot of effort and thought by many individuals. They are posted here to make that work
more easily accessible. This historical archive many serve as a resource to future regulators and safety advocates, so
they don’t have to start from scratch. OSHA has removed some of these documents from their website
which makes access difficult.
To the best of our knowledge this is a complete archive of ACCSH working group reports and recommendations. If you are aware
of others, please contact us. For the most recent or future meetings, you can find information at http://www.osha.gov/doc/accsh .
|
REPORT TO THE ADVISORY COMMITTEE ON CONSTRUCTION SAFETY AND HEALTH
SUBMITTED BY THE SUBCOMMITTEE ON FATALITY/CATASTROPHE INVESTIGATIONS
JOE ADAM
V. SHERWOOD KELLY
JIM E. LAPPING
MARCH 29, 1988
On May 23, 1983, the Advisory Committee on Construction Safety and Health's (ACCSH) Subcommittee on Fatality Catastrophe
Investigations reported its recommendations to the full committee (see below). The recommendations were discussed
by the ACCSH and approved and transmitted to the OSHA administration.
Since the report OSHA has done little to act on the ACCSH recommendations. The only positive action has been the Fatal
Facts reports recently instituted by OSHA (see below).
The Bridgeport L'Ambiance Plaza tragedy again focused attention on many of the deficiencies associated with OSHA's
fatality/catastrophe investigation and reporting procedures. The ACCSH has ben briefed on the accident and the deficiencies
so they will not be repeated in this report.
The present members of the subcommittee agree that the issues discussed by the ACCSH on May 23, 1983, and the recommendations
made to OSHA by the ACCSH are still topical and important.
Our recommendation is that the ACCSH request that OSHA, at the next ACCSH meeting, provide to the committee a detailed
briefing regarding the following issues.
ISSUE 1
Has OSHA taken any action to lower the present 48 hour reporting time allowed by 29 CFR 1904.8? (see below) If
not, why not?
ISSUE 2
Has OSHA taken any action to require the initial report to be by telephone or telegram? If not, why not?
ISSUE 3
OSHA regulation 29 CFR 1904.8 now requires an employer to report to OSHA within 48 hours any employment accident
which results in the hospitalization of 5 or more employees. Has OSHA taken any action to lower this number? If not,
why not?
ISSUE 4
Has OSHA taken any action to require the employer to freeze the accident site until OSHA completes its physical
investigation? If this action requires a change in the OSHA act, would OSHA support such a change? If not, why not?
ISSUE 5
Does OSHA have a 24 hour national 800 watts line available to employers and employees to report a fatality/catastrophe?
If not, why not? If OSHA has this number, has it been made available to hospitals and clinic emergency rooms? If not,
why not?
ISSUE 6
Has OSHA required state plan states to develop and implement the Fatal Facts program in their states? If not,
why not?
ISSUE 7
Does OSHA require the area office or state agency investigating each and every fatality/catastrophe to issue a final
report to the national office stating the answers to the 4 questions found in the OSHA Field Operation Manual 'Chapter
VIII, Para. A3 (a) (b)(c)(d)? (see below) If not, why not?
ISSUE 8
Has OSHA initiated any action to improve the present reporting system t o eliminate or at least substantially
reduce the amount of under-reporting of accidents and injury now present in those employments covered by OSHA? If not,
why not?
The subcommittee recognizes that some of the issues presented overlap issues discussed by other ACCSH subcommittees.
We believe that this overlap is unavoidable and further emphasizes the scope and size of the continuing unresolved
problems that OSHA seems unwilling to confront.
We strongly urge the full committee to approve the subcommittee's recommendation that the ACCSH request that OSHA,
at the next meeting, provide the full committee a detailed briefing regarding the 8 listed issues.
ACCIDENT SUMMARY
Accident Summary |
Electrocution |
Weather |
Clear |
Type of Operation |
Power Line Work |
Crew Size |
2 |
Collective Bargaining? |
Yes |
Competent Safety Monitor on Site? |
Yes |
Safety and health Program in Effect? |
No |
Was the Worksite Inspected Regularly by the Employer? |
No |
Training and Education Provided? |
No |
Employee Job Title |
Lineman |
Age/Sex |
44/M |
Experience at this Type Work |
11 Months |
Time on Project |
6 Weeks |
BRIEF DESCRIPTION OF ACCIDENT
A lineman was electrocuted while working on grounded deenergized lines. He
was working from a defective basket on an articulated boom aerial lift when the basket contacted energized
lines which ran beneath the deenergized lines The defective basket permitted current to pass through a
drain hole cut into the body of the basket, then through the employee, and to ground via the deenergized
line.
INSPECTION RESULTS
OSHA cited the company for two serious violations and one other than serious violation
of its construction standards. Had barriers been erected to prevent contact with adjacent energized lines,
the electrical shock might have been prevented.
ACCIDENT PREVENTION RECOMMENDATIONS
1. Guards or barriers must be erected as necessary to adjacent energized
lines (29 CFR 1926.950(d)(l)(v)).
2. Existing conditions of mechanical equipment, energized lines, equipment,
conditions of poles, and location of circuit must be determined by an inspection or test before starting
work (29 CFR 1926.950(b)(1) and .952(a)(1)).
3. Employees must be instructed on how to recognize and
avoid unsafe conditions and on regulations that apply to their work environment (29 CFR 1926.21 )(b)(2)).
SOURCES OF HELP
Construction Safety and Health Standards (OSHA 2207) which contains all OSHA job safety
and health rules and regulations (1926 and 1910) covering construction.
OSHA-funded free consultation
services. Consult your telephone directory for the number of your local OSHA area or regional office for
further assistance and advice (listed under U.S. Labor Department or under the state government section
where states administer their own OSHA programs).
OSHA Safety and Health Training Guidelines for Construction
(available from the National Technical Information Service-Order No PB-239-312/AS) comprised of a set of
15 guidelines to help construction employees establish a training program in the safe use of equipment,
tools, and machinery on the job.
NOTE: The case here described was selected as being representative of fatalities caused by improper
work practices. No special emphasis or priority is implied nor is the case necessarily a recent occurrence.
The legal aspects of the incident have been resolved. and the case is now closed.
|
CHAPTER Vlll
FATALITY/CATASTROPHE INVESTIGATIONS
A. General.
I . Policy. All job-related fatalities and catastrophes, however reported, shall
be investigated as thoroughly and expeditiously as resources and other priorities permit.
2. Definitions. The following definitions apply for purposes of this chapter:
a. Fatality. An employee death resulting from an employment accident or illness:
in general, from an accident or illness caused by or related to a workplace hazard.
b. Catastrophe. The hospitalization
of five or more employees resulting from an employment accident or illness; in general, from an accident
or illness caused by a workplace hazard.
NOTE: “Accidents involving significant publicity” or any other accident
not involving a fatality or a catastrophe, however reported, shall be considered as either a complaint
or a referral, depending on the source of the report, and shall be handled according to the directions
given in Chapter IX. Accidents discovered from a records review or during the walkaround on a programmed
inspection shall be handled as part of the programmed inspection in accordance with Chapter II. E.2.b.
c. Hospitalization. To be sent to, to go to, or to be admitted to a hospital or
equivalent medical facility for examination or treatment, irrespective of whether or not treatment
was actually provided or what the length of stay in the hospital was.
d. Reporting. Area Directors and District Office Supervisors shall report multiple
fatalities and catastrophes directly and immediately to the Regional Administrator, who shall inform
the Director of Field Operations in accordance with the instructions given in C.1.
NOTE:
For purposes of the reporting requirement of this paragraph,"multiple fatalities and catastrophes"
shall include the following:
(1) Fatalities totaling two or more;
(2) All catastrophes;
(3) Single fatalities involving or likely to involve significant national or local publicity; or
(4) Single fatalities involving extensive property damage
3. Fatality/Catastrophe investigations. Upon initial
contact the employer shall be informed that
an investigation will be conducted and extensive
interviews with witnesses will be necessary.
The purpose of an accident investigation shall be
explained, namely, to determine:
a. The cause of the accident.
b. Whether a violation of OSHA safety or health standards related to the accident
occurred.
c. What effect the standard violation had on the occurrence of the accident.
d. If OSHA standards
should be revised to correct the hazardous working condition that led to the accident.
B. Action.
1. Preinvestigation Activities. It is essential to the proper conduct of a fatality or catastrophe
investigation that preparations be carefully made. OSHA will often be the subject of public scrutiny
in the conduct of such investigations, and it is imperative that they be complete and professionally
competent.
a. Area Director. If the fatality or catastrophe appears to require an OSHA investigation
(i.e., it is or may be occupationally related and OSHA’s jurisdiction is not preempted), the
Area Director shall ensure that the required IMIS forms are completed and shall report the event
to the Regional Administrator and give all pertinent information to the National Office, when required
by C.l, as soon as it is
|
1904.7-ACCESS TO RECORDS
(a) Each employer shall provide, upon request records provided for in §§ 1904.2,
1904.4, and 1904.5, for inspection and copying by any representative of the Secretary of
Labor for the purpose of carrying out the provisions of the act, and by representatives
of the Secretary of Health, Education, and Welfare during any investigation under section
20(b) of the act, or by any representative of a State accorded jurisdiction for occupational
safety and health inspections or for statistical compilation under sections 18 and 24 of
the act.
(b)
(1) The log and summary of all recordable occupation injuries and illnesses (OSHA No.
200) (the log) provided for in § 1904.2 shall, upon request, be made available by the employer to
any employee, former employee, and to their representatives for examination and
copying in a reasonable manner and at reasonable times. The employee, former employee,
and their representatives shall have access to the log for any establishment in which the employee is or
has been employed.
(2) Nothing in this section shall be deemed to preclude employees and employee representatives
from collectively bargaining to obtain access to information relating to occupational injuries and illnesses
in addition to the information made available under this section.
(3) Access to the log provided under this section shall pertain to all logs retained
under the requirements of § 1904.6.
[43 F.R. 31329, July 21,1978.1]
1904.8-REPORTING OF FATALITY OR MULTIPLE
HOSPITALIZATION ACCIDENTS
Within 48 hours after the occurrence of an employment accident which is fatal to one or more employees or which results
in hospitalization of five or more employees, the employer of any employees so injured or killed shall report the accident
either orally or in writing to the nearest office of the Area Director of the Occupational Safety and Health Administration,
U.S. Department of Labor. The reporting may be by telephone or telegraph. The report shall relate the circumstances of the
accident, the number of fatalities, and the extent of any injuries. The Area Director may require such additional reports,
in writing or otherwise, as he deems necessary, concerning the accident.
|
REPORT TO THE ADVISORY COMMITTEE ON CONSTRUCTION SAFETY AND HEALTH
BY THE
SUBCOMMITTEE ON FATALITY/CATASTROPHE INVESTIGATIONS
JOE ADAM
V. SHERWOOD KELLY
JIM E. LAPPING
MAY 23, 1983
On December 1, 1982 chairman Ed Lore appointed a three member sub-committee (SC) to investigate OSHA's fatality/catastrophe
investigation procedure. The SC was instructed to recommend to the full committee whether the subject of fatality/catastrophe
investigations should be an agenda item.
The SC, through a conference call, discussed the issue on April 27, 1983. It was agreed that the issue of fatality/catastrophe
investigations should be made an announced committee agenda item for the next meeting.
The SC also reviewed various OSHA documents and decided to present to the committee an outline of OSHA's present fatality/catastrophe
investigations system. We also developed some discussion points on which the committee may wish to focus attention.
The present OSHA fatality/catastrophe investigation process is based upon the OSHA Act passed by Congress in 1970, and the
supporting regulations and policy documents developed by the OSHA Administration. Some of these documents were sent to the
committee by Ken Hunt.
Section 8(a) (1) of the OSHAct authorizes OSHA to enter any workplace where work is performed, and Section 8(a) (2) authorizes
OSHA to inspect and investigate any such place of employment and to question employers and employees.
Section 8(c) (2) requires OSHA to prescribe regulations requiring employers to maintain accurate records of, and to make
reports on, work -related deaths, injuries and illnesses.
OSHA regulation 29 CFR 1904.8 requires employers to report to OSHA, within 48 hours, fatal accidents or accidents resulting
in multiple hospitalizations.
OSHA's Field Operation Manual (FOM) Chapter VIII interprets OSHA policy on fatality/catastrophe investigations.
Probably the most important language in FOM Chapter VIII is found in Section A3. Section A3 states that "Upon initial
contact the employer shall be informed that an investigation will be conducted and extensive interviews with witnesses will
be necessary. The purpose of an accident investigation shall be explained, namely, to determine:
a. The cause of the accident.
b. Whether a violation of OSHA safety or health standards related to the accident occurred.
c. What effect the standard violation had on the occurrence of the accident.
d. If OSHA standards should be revised to correct the hazardous working condition that led to the accident ."
On May 2, 1983 OSHA initiated a Pilot: Program on fatality/catastrophe investigations in one area office in each of
regions IV, V and VII. The announcement of this program was included in the committee mailing.
In May 1979 the Comptroller General of the General Accounting Office submitted a report to the Congress. The report is titled "How
car Workplace Injuries Be Prevented? The Answers May Be In OSHA Files." The report is critical of OSHA's 1979 and
prior record in using information gathered in serious work-related accidents. The report recommends that OSHA should:
-- define and designate the responsibility for data collection and analysis, and require that program offices'
needs be surveyed and recognized in data systems designs;
-- revise procedures for reporting investigation information to better classify and describe hazards causing serious
accidents and countermeasures to help prevent similar accidents;
-- establish lists of hazards which warrant special emphasis in standards development, enforcement, and education
and training;
-- provide information on the causes of fatal and other serious accidents for industries and labor groups to use
in identifying hazards and preventing accidents;
-- have States submit information on State accident investigations and incorporate such information into the data
system; and
-- require each major program office to report annually on how its activities were directed at areas with the highest
number of fatal and other serious accidents and the results of their efforts.
After discussion the SC agreed that the following subjects deserve the attention of the full committee at subsequent
meetings.
1. Should 29 CFR 1904.8 be amended to lower the 48 hour reporting time?
2. Should 29 CFR 1904.8 be amended to require the report to be by telephone or telegraph"
3. Should 29 CFR 1904.8 be amended-to lower the multiple injury reporting requirement from 5 to some lower number?
4. Should language be added to 1904.8 requiring the "freezing" of the accident site until federal or state
OSHA completes its investigation of the physical evidence? Should the freeze apply to multiple hospitalization accidents
as well as fatal accidents? Along with this discussion there should be consideration of a maximum time limit for
OSHA to respond before the site can be "thawed"?
5. Are there valid reasons why OSHA does not have a 800 watts line available to employers to report fatality /catastrophes?
Should hospital and clinic emergency rooms be made aware of this number?
6. Should OSHA and state plan states be asked to develop a system of Fatalgrams similar to those currently used
by the Mine Safety and Health Administration (MSHA) ?
7. Should FOM Chapter VlII be revised to require federal and state compliance officers to report on each of the
four items listed in Section A3?
8. Should language be added to FOM Chapter VI11 requiring that a narrative description of the accident be transmitted
to the national office of all federal and state fatality/catastrophe investigations? The narrative would include
an account of the accident, possible causes, and recommendations for preventing similar accidents in the future.
9. The committee should discuss how information regarding fatality/catastrophe investigations can be quickly communicated
to the affected industry employers and employees.
10. The committee can consider asking OSHA for a report on how Bureau of Labor Statistics (BI) accident information
is coordinated and utilized by OSHA.
11. The SC agreed that there should be discussion on whether OSHA should be required to publicly report federal
and state fatality/catastrophe statistics on a periodic basis such as monthly or quarterly.
|
OSHA Advisory Committee for Construction Safety and Health (ACCSH)
This paper appears in the eLCOSH website with the permission of the author and/or copyright holder and may not be reproduced without their consent. eLCOSH is an information clearinghouse. eLCOSH and its sponsors are not responsible for the accuracy of information provided on this web site, nor for its use or misuse.
eLCOSH
| CDC | NIOSH
| Site Map | Search
| Links | Help
| Contact Us | Privacy Policy |