International Brotherhood of Teamsters TABLE OF CONTENTS The Problem The Purpose
Permit-Required Confined Space SECTION II Control of Hazardous Energy (Lockout/Tagout) SECTION III Respiratory Hazards SECTION IV Noise Hazards SECTION V Conclusions Ready-mixed concrete trucks are equipped with a rotating mixing drum mounted on the truck chassis. During loading, transport, and delivery to the construction site, the mixing drum is constantly rotated to prevent concrete hardening within the drum. The cleaning of the mixing drums becomes necessary as the drum interior becomes coated with hardened concrete. Workers are required to enter the mixing drums periodically to remove the hardened concrete. This cleaning operation presents many hazards to the workers including confined space, hazardous energy, respiratory hazards, and noise, all of which require the employer to implement comprehensive programs to address each hazard. The Purpose The purpose of this publication is to inform you of the primary hazards associated with the cleaning operation so that you and your fellow workers can protect yourselves. SECTION I Permit-Required Confined Space The Occupational Safety and Health Administration (OSHA) considers ready-mixed concrete mixing drums "permit-required confined spaces". According to OSHA, a permit-required confined space (permit space) "means a confined space that has one or more of the following characteristics: 1. Contains or has a potential to contain a hazardous atmosphere; 2. Contains a material that has the potential for engulfing an entrant; 3. Has an internal configuration such that an entrant could be trapped or asphyxiated by inwardly converging walls or by a floor which slopes downward and tapers to a smaller cross-section; or 4. Contains any other recognized serious safety or health hazard." Entry into permit spaces is generally governed by a comprehensive program that includes provisions for detailed hazard evaluation, written entry permits, employee training, and emergency planning. Employers requiring workers to enter ready-mixed concrete mixers must comply with all requirements set forth in 29 CFR 1910.146 "Permit-Required Confined Spaces" even if this work is contracted to a third party. The OSHA standard requires that the employer: 1. Implement measures to prevent unauthorized entry into the drum; 2. Identify and evaluate the hazards of the drums before employees enter them; 3. Develop and implement the procedures and practices necessary for safe permit space entry operations; 4. Provide the following equipment at no cost to employees:
6. Provide at least one attendant outside the drum for the duration of the operation; 7. Include in the permit program the means and procedures to enable an attendant to respond to an emergency affecting one or more of the drums being monitored without distraction from the attendant's other responsibilities as outlined in the standard; 8. Designate the persons who are to have active roles (for example, authorized entrants, attendants, entry supervisors, or persons who test or monitor the atmosphere in the drum) in entry operations, identify the duties of each employee, and provide each employee with the training required; 9. Develop and implement procedures for contacting rescue and emergency services. Just dialing 911 is not sufficient! The employer must have a system set up with a local emergency service with confined space rescue capabilities and training; 10. Develop a system for the preparation, issuance, use, and cancellation of entry permits; 11. Develop procedures to coordinate entry operations when employees of more than one employer are working simultaneously as authorized entrants in a drum. This will prevent accident and injury due to a lack of communication and coordination; 12. Develop and implement procedures (such as closing off a drum and canceling the permit) necessary for concluding the entry after entry operations have been completed; 13. Review entry operations when the employer has reason to believe that the measures taken under the permit space program may not protect employees; 14. Review the permit space program, using the canceled permits retained within one (1) year after each entry and revise the program as necessary, to ensure that employees participating in entry operations are protected from hazards within the drum. -Entry Permit- Before entry into a drum is authorized, the employer must document the completion of measures required by the standard by preparing an entry permit. The entry permit must identify:
Control of Hazardous Energy (Lockout/Tagout) The OSHA Lockout/Tagout standard (29 CFR 1910.147) covers the servicing and maintenance of equipment and machinery that could cause injury to employees if unexpectedly started or energized. Employees performing cleaning activities inside mixing drums are covered by this standard because unexpected startup of the mixer can cause serious injury or death to the worker. Employers requiring workers to enter ready-mixed concrete mixers must comply with all requirements set forth in 29 CFR 1910.147 "Control of Hazardous Energy" even if this work is contracted out. Under the Lockout/Tagout standard, employers are required to:
The following lockout/tagout procedures should be used as a guide to preparing the truck for work inside the mixer drum:
Respiratory Hazards OSHA's Respiratory Protection standard (29 CFR 1910.134) requires that the employer provide respirators when necessary to protect the health of workers. The standard also requires that the employer establish and maintain a respiratory protection program. Employers requiring workers to enter concrete mixers to chip them out must comply with all requirements set forth in the Respiratory Protection standard even if this work is contracted out. The primary respiratory hazard associated with chipping operations inside mixing drums is crystalline silica. Silica is an ingredient of ready-mixed concrete that becomes airborne during jackhammering operations. Exposure to silica causes silicosis, a disabling, nonreversible and sometimes fatal lung disease caused by overexposure to respirable crystalline silica. More than one million U.S. workers are exposed to crystalline silica, and each year more than 250 die from silicosis. There is no cure for the disease, but it is 100 percent preventable if employers, workers, and health professionals work together to reduce exposures. OSHA has established a Permissible Exposure Limit (PEL) for silica. When working at concentrations above the PEL, all employees are required to wear respiratory protection if the hazard cannot be controlled through other means. Employers requiring workers to enter ready-mixed concrete mixers must comply with all requirements set forth in 29 CFR 1910.134 "Respiratory Protection". The Respiratory Protection Program must include the following provisions:
The employer must also provide effective training to those employees required to wear respirators. The training must be comprehensive, understandable, and recur annually, and more often if necessary. The employer must provide a variety of choices of respirators for employees so that each employee can select a respirator that fits properly and comfortably. According to the National Institute for Occupational Safety and Health (NIOSH), assuming that all atmospheric testing requirements have been satisfied, it is recommended that the workers wear any air-purifying, full face-piece respirator with a high-efficiency particulate filter, preferably a powered air-purifying respirator, for adequate respiratory protection during the drum cleaning operation . SECTION IV Noise Hazards NIOSH studies have shown that drivers involved in mixer chipping operations are at risk for noise-induced hearing loss. Chipping operations inside the concrete mixing drum using a jackhammer pneumatic chipper can reach sound levels of to 113 decibels. OSHA's Occupational Noise Exposure standard (29 CFR 1910.95) requires that an employer implement a hearing conservation program when employees are exposed to sound levels in excess of 85 decibels when averaged over an 8-hour work shift. Employers requiring workers to enter ready-mixed concrete mixers must comply with all requirements set forth in 29 CFR 1910.95 "Occupational Noise Exposure" if the workers are exposed to noise above the OSHA action level of 85 dBA. The hearing conservation program consists of noise monitoring, noise control, audiometric (hearing) tests, hearing protection, employee training and education, and record keeping.
Conclusions The purpose of this educational material is twofold. First, a lot of ready - mixed concrete companies are contracting out mixer chipping work because they are under the false impression that they do not have to establish these programs if they use a third party. On the contrary, the employer cannot avoid responsibility for the safety and health of the workers by contracting the work out. Furthermore, the employer must implement the confined space and lockout/tagout programs regardless of who performs the work. Armed with this information, the local union can negotiate to keep this work inhouse and ensure that the work is done safely. Second, if the local union already performs this work, or if the local union decides to negotiate for this work, the union representatives must be informed of what is required of the employer. The programs must be developed and implemented by the employer. These programs are required by OSHA to protect workers while they perform this potentially hazardous work. The employer is required by OSHA to provide copies of these safety and health programs to the local union upon request. If you are unsure whether or not your employer is required to develop these programs, or if you need assistance with requesting copies of these programs, please contact the IBT Safety and Health Department at (202) 624-6960. This document appears in the eLCOSH website with the permission of the author and/or copyright holder and may not be reproduced without their consent. eLCOSH is an information clearinghouse. eLCOSH and its sponsors are not responsible for the accuracy of information provided on this web site, nor for its use or misuse. eLCOSH | CDC | NIOSH | Site Map | Search | Links | Help | Contact Us | Privacy Policy |