[Federal Register: June 22, 2005 (Volume 70, Number 119)]
[Rules and Regulations]               
[Page 35992-35993]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr22jn05-4]                         


[[Page 35992]]

-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2004-18496; Directorate Identifier 2004-NE-04-AD; 
Amendment 39-14143; AD 2005-13-07]
RIN 2120-AA64

 
Airworthiness Directives; Honeywell International Inc. (Formerly 
AlliedSignal Inc. and Garrett Turbine Engine Co.) TFE731-2 and -3 
Series Turbofan Engines

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: The FAA is adopting a new airworthiness directive (AD) for 
Honeywell International Inc. (formerly AlliedSignal Inc. and Garrett 
Turbine Engine Co.) TFE731-2 and -3 series turbofan engines with 
certain part numbers (P/Ns) and serial numbers (SNs) of low pressure 
(LP) 1st and 2nd stage turbine rotor discs initially installed. This AD 
requires replacement of those LP 1st and 2nd stage turbine rotor discs. 
This AD results from a report of an uncontained failure of an LP 2nd 
stage turbine rotor disc that resulted in an in-flight engine shutdown. 
We are issuing this AD to prevent LP turbine rotor disk separation, 
which could result in an uncontained engine failure and damage to the 
airplane.

DATES: This AD becomes effective July 27, 2005. The Director of the 
Federal Register approved the incorporation by reference of certain 
publications listed in the regulations as of July 27, 2005.

ADDRESSES: You can get the service information identified in this AD 
from Honeywell Engines and Systems (formerly AlliedSignal Inc. and 
Garrett Turbine Engine Co.) Technical Publications and Distribution, M/
S 2101-201, P.O. Box 52170, Phoenix, AZ 85072-2170; telephone: (602) 
365-2493 (General Aviation), (602) 365-5535 (Commercial Aviation), fax: 
(602) 365-5577 (General Aviation), (602) 365-2832 (Commercial 
Aviation).
    You may examine the AD docket on the Internet at http://dms.dot.gov 

or in Room PL-401 on the plaza level of the Nassif Building, 400 
Seventh Street, SW., Washington, DC.

FOR FURTHER INFORMATION CONTACT: Joseph Costa, Aerospace Engineer, Los 
Angeles Aircraft Certification Office, FAA, Transport Airplane 
Directorate, 3960 Paramount Blvd., Lakewood CA 90712-4137; telephone: 
(562) 627-5246; fax: (562) 627-5210.

SUPPLEMENTARY INFORMATION: The FAA proposed to amend 14 CFR part 39 
with a proposed AD. The proposed AD applies to Honeywell International 
Inc. (formerly AlliedSignal Inc. and Garrett Turbine Engine Co.) 
TFE731-2 and -3 series turbofan engines with certain P/Ns and SNs of LP 
1st and 2nd stage turbine rotor discs initially installed as new parts 
before April 1, 1991. These discs were heat treated with a process that 
may have resulted in disk material with a non-uniform microstructure 
that is susceptible to creep fatigue, which may lead to cracking or 
separation. We published the proposed AD in the Federal Register on 
July 1, 2004 (69 FR 39875). That action proposed to require replacement 
of those LP 1st and 2nd stage turbine rotor discs.

Examining the AD Docket

    You may examine the docket that contains the AD, any comments 
received, and any final disposition in person at the DMS Docket Offices 
between 9 a.m. and 5 p.m., Monday through Friday, except Federal 
holidays. The Docket Office (telephone (800) 647-5227) is located on 
the plaza level of the Department of Transportation Nassif Building at 
the street address stated in ADDRESSES. Comments will be available in 
the AD docket shortly after the DMS receives them.

Comments

    We provided the public the opportunity to participate in the 
development of this AD. We received no comments on the proposal or on 
the determination of the cost to the public.

Conclusion

    We have carefully reviewed the available data and determined that 
air safety and the public interest require adopting the AD as proposed.

Costs of Compliance

    There are about 56 Honeywell International Inc. TFE731-2 and -3 
series turbofan engines of the affected design in the worldwide fleet. 
We estimate that 24 engines installed on airplanes of U.S. registry 
will be affected by this AD. We also estimate that it will take about 4 
work hours per engine to perform these actions, and that the average 
labor rate is $65 per work hour. Required parts cost about $30,000 per 
engine. Based on these figures, we estimate the total cost of this AD 
to U.S. operators to be $726,240.

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, Section 106, describes the 
authority of the FAA Administrator. Subtitle VII, Aviation Programs, 
describes in more detail the scope of the Agency's authority.
    We are issuing this rulemaking under the authority described in 
Subtitle VII, Part A, Subpart III, Section 44701, ``General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this 
rulemaking action.

Regulatory Findings

    We have determined that this AD will not have federalism 
implications under Executive Order 13132. This AD will not have a 
substantial direct effect on the States, on the relationship between 
the national government and the States, or on the distribution of power 
and responsibilities among the various levels of government.
    For the reasons discussed above, I certify that this AD:
    (1) Is not a ``significant regulatory action'' under Executive 
Order 12866;
    (2) Is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and
    (3) Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.
    We prepared a summary of the costs to comply with this AD and 
placed it in the AD Docket. You may get a copy of this summary at the 
address listed under ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

0
Accordingly, under the authority delegated to me by the Administrator, 
the Federal Aviation Administration amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:


[[Page 35993]]


    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. The FAA amends Sec.  39.13 by adding the following new airworthiness 
directive:

2005-13-07 Honeywell International Inc. (formerly AlliedSignal Inc. 
and Garrett Turbine Engine Co.): Amendment 39-14143. Docket No. FAA-
2004-18496; Directorate Identifier. 2004-NE-04-AD.

Effective Date

    (a) This airworthiness directive (AD) becomes effective July 27, 
2005.

Affected ADs

    (b) None.

Applicability

    (c) This AD applies to Honeywell International Inc. (formerly 
AlliedSignal Inc. and Garrett Turbine Engine Co.) TFE731-2 and -3 
series turbofan engines with the following low pressure (LP) 1st and 
2nd stage turbine rotor disc part numbers (P/Ns), with serial 
numbers (SNs) listed in Tables 1, 2, and 3 of Honeywell 
International Inc. SB No. TFE731-72-3682, dated November 26, 2002, 
initially installed as new parts before April 1, 1991:

                              Part Numbers
------------------------------------------------------------------------

------------------------------------------------------------------------
3072069-All..............................  3073014-All
3072070-All..............................  3073113-All
3072351-All..............................  3071114-All
3072542-All..............................  3074103-All
3073013-All..............................  3074105-All
------------------------------------------------------------------------
(All denotes all dash numbers installed)

    These engines are installed on, but not limited to, the 
following airplanes:

Avions Marcel Dassault Mystere-Falcon 10 and 50 series
Cessna Model 650, Citation III, and Citation VI
Gulfstream Aerospace LP (formerly IAI) 1125 Westwind Astra series
Israel Aircraft Industries (IAI) 1124 series
Learjet 31, 35, 36, and 55 series
Lockheed-Georgia 1329-25 series (731 Jetstar, Jetstar II)
Raytheon Corporate Jets (formerly British Aerospace) DH/HS/BH-125
 series;
Sabreliner NA-265-65 (Sabreliner 65)


Unsafe Condition

    (d) This AD results from a report of an uncontained failure of 
an LP 2nd stage turbine rotor disc that resulted in an in-flight 
engine shutdown. We are issuing this AD to prevent LP turbine rotor 
disk separation, which could result in an uncontained engine failure 
and damage to the airplane.

Compliance

    (e) You are responsible for having the actions required by this 
AD performed within the compliance times specified unless the 
actions have already been done.

Removal From Service of LP 1st and 2nd Stage Turbine Rotor Discs

    (f) For TFE731-2-2J, TFE731-2-2N, TFE731-2A-2A, and TFE731-3-1J 
engines, replace discs that are listed by SN in Tables 1 and 3 of SB 
No. TFE731-72-3682, dated November 26, 2002, within 100 hours time-
in-service (TIS) after the effective date of this AD.
    (g) For TFE731-2 series engines except TFE731-2-2J, TFE731-2-2N, 
and TFE731-2A-2A engines, replace discs that are listed by SN in 
Tables 1 and 2 of SB No. TFE731-72-3682, dated November 26, 2002, at 
the next Major Periodic Inspection (MPI) or next access to the 
turbine discs after the effective date of this AD, but within 2,200 
hours TIS since the last disc inspection, whichever occurs first.
    (h) For TFE731-3 series engines except TFE731-3-1J, replace 
discs that are listed by SN in Table 3 of SB No. TFE731-72-3682, 
dated November 26, 2002, at the next MPI or next access to the 
turbine discs after the effective date of this AD, but within 1,500 
hours TIS since the last disc inspection, whichever occurs first.
    (i) Information on replacing affected discs can be found in 
Honeywell International Inc. SB No. TFE731-72-3682, dated November 
26, 2002.
    (j) After the effective date of this AD, do not install any LP 
1st and 2nd stage turbine rotor disc that has a SN listed in Table 
1, 2, or 3 of SB No. TFE731-72-3682, dated November 26, 2002, and 
determined to be manufactured before April 1, 1991.

Definitions

    (k) For the purposes of this AD, access to the turbine discs is 
the level of disassembly that has removed the tie-shaft nut.

Alternative Methods of Compliance

    (l) The Manager, Los Angeles Aircraft Certification Office, has 
the authority to approve alternative methods of compliance for this 
AD if requested using the procedures found in 14 CFR 39.19.

Material Incorporated by Reference

    (m) You must use Honeywell International, Inc. Service Bulletin 
No. TFE731-72-3682, dated November 26, 2002, to perform the 
replacements required by this AD. The Director of the Federal 
Register approved the incorporation by reference of this service 
bulletin in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. 
Contact Honeywell Engines and Systems Technical Publications and 
Distribution, M/S 2101-201, P.O. Box 52170, Phoenix, AZ 85072-2170; 
telephone: (602) 365-2493 (General Aviation), (602) 365-5535 
(Commercial Aviation), fax: (602) 365-5577 (General Aviation), (602) 
365-2832 (Commercial Aviation) for a copy of this service 
information. You may review copies at the Docket Management 
Facility; U.S. Department of Transportation, 400 Seventh Street, 
SW., Nassif Building, Room PL-401, Washington, DC 20590-0001, on the 
internet at http://dms.dot.gov, or at the National Archives and 

Records Administration (NARA). For information on the availability 
of this material at NARA, call 202-741-6030, or go to: http://www.archives.gov/federal_register/code_of_federal_regulations/ibr_locations.html
.


Related Information

    (n) None.

    Issued in Burlington, Massachusetts, on June 13, 2005.
Francis A. Favara,
Acting Manager, Engine and Propeller Directorate, Aircraft 
Certification Service.
[FR Doc. 05-12080 Filed 6-21-05; 8:45 am]

BILLING CODE 4910-13-P