|
FSIS Technical Service Center Common BSE Questions and Answers
|
|
|
1. Will the Department take regulatory control actions on products prohibited under the December
30 announcement that are currently in the distribution chain?
The rules will not be retroactive. The non-ambulatory disabled ban took effect December 30. The
interim rules only apply to products that are derived from cattle slaughtered on or after Monday,
January 12, 2004.
[Top of Page]
2. What is "presented" for slaughter? Can the animals be removed from the premises if not presented?
Animals that are identified to inspection program personnel for ante-mortem inspection and are on the
premises (or have not been specifically excluded from inspection) are considered to be presented. They
can be removed if they have not been presented and have no other restrictions placed on them. If they have
been presented, they can be removed with the permission of, and under the supervision of, the proper officials.
[Top of Page]
3. Are (bob veal) calves under the same restrictions?
All cattle, (i.e. bovines: Bos taurus, Bos indicus) not all ruminants, are subject to
the provisions of the non-ambulatory disabled rule. This includes calves. The existing regulatory
provisions providing for treating animals on site, or moving to another location remain.
[Top of Page]
4. If a non-ambulatory disabled animal is brought on an official establishment premises, but not removed
from the transport vehicle and not presented for inspection, what is FSIS's role?
FSIS is to ensure that the animal is humanely handled.
[Top of Page]
5. Are FSIS VMOs to call APHIS for dead animals on the transport vehicles coming on official premises or
ones that are rejected by the establishment and have not been presented for inspection?
No.
[Top of Page]
6. Are FSIS VMOs to call APHIS for any/all non-ambulatory disabled cattle condemned by FSIS?
Yes, VMOs should call the Area Veterinarian-In-Charge (AVIC). The call should be documented with the name
of the APHIS contact and whether APHIS decided to test. Helpful information that FSIS VMOs may provide
include whether the animal was non-ambulatory disabled and whether the animal exhibited CNS signs.
This is further discussed in FSIS Notice 5-04.
[Top of Page]
7. If a sample is taken by APHIS from a non-ambulatory disabled animal and the plant has no capability to
hold the carcass pending test results where can the carcass be taken?
Carcasses can be sent to a lined landfill, in accordance with state or local sanitary codes. The
establishment must maintain records of carcass disposition. These records should include the identification
of the animal.
[Top of Page]
8. When establishments are slaughtering non-segregated animals of mixed ages (both less than 30 months as
well as 30 months and older) what is the required intervention for cleaning the equipment (e.g., splitting
saw) between animals?
All plants that slaughter cattle and/or process cattle carcasses or parts have the responsibility of
developing, implementing, and maintaining written procedures for the removal, segregation, and
disposition of Specified Risk Materials (SRMs.) These procedures must be incorporated into the
plant's HACCP plans, SSOPs, or other pre-requisite program.
This could be accomplished by segregating the older (30 months and older) and younger (less than 30 months)
cattle, then slaughtering and processing the younger cattle first, followed by the older animals.
The establishment should be cleaned and sanitized before slaughtering the next group of younger
animals to prevent cross-contamination of the younger cattle with SRMs from the older cattle.
The establishment can also determine other acceptable means to meet these requirements.
For example, when 30 months of age and older cattle are intermingled with younger cattle, an establishment
may include cleaning and sanitizing procedures in their operational sanitation SOPs for equipment to
prevent cross contamination. These procedures need to address sanitation between slaughter of animals
30 months of age and older and subsequent younger animals. Please refer to FSIS Notice 10-04.
[Top of Page]
9. Can T-bones, brains, and the like, be saved from older animals (30 months and older) in custom
exempt facilities?
SRMs are considered adulterated and ineligible for human food. This applies to custom slaughter as
well as to inspected operations. As such, traditional bone-in cuts of beef, such as T-bones, porterhouse,
and rib roasts cannot be saved for human food, unless the SRM portion of the cut (i.e. the vertebral
column) is removed, resulting in a semi-boneless cut. The other alternative is to completely bone
out the product.
[Top of Page]
10. Can I cut steaks from the loins of cattle 30 months of age or older first and then remove the SRMs
associated with the vertebral column?
No, at this time FSIS believes that potential contamination with exposed dorsal root ganglia (DRG) should
be limited to the maximum extent practical and does not view this additional contamination as necessary
or appropriate.
[Top of Page]
11. Must the SRMs be removed at slaughter?
No, there is no requirement to remove the SRMs at slaughter. The carcasses/parts can be shipped to
another inspected facility provided documentation to ensure the removal of the SRMs from products for
human food accompanies the product. The shipping establishment must consider in their hazard analysis,
decisions on food safety hazards that can occur before, during, and after entry into the establishment.
[Top of Page]
12. Are the SRMs allowed to go to inedible rendering?
SRMs are currently not restricted from entering inedible channels (e.g. rendering); however, when an animal
is being tested by APHIS for BSE, FSIS inspection personnel should request that the SRMS not go into
inedible rendering until a negative BSE result is obtained.
[Top of Page]
13. If SRMs are not rendered can they be denatured and sent to an approved landfill?
FSIS considers it acceptable to send carcasses or parts from animals that are being tested by APHIS for
BSE to a lined landfill, in accordance with state or local sanitary codes, when a test result has not
yet been received. The establishment must maintain accurate records documenting the location of carcass
or parts disposal.
[Top of Page]
14. If the establishment is removing the meat from around the vertebral column with electric ("wizard")
knives, is this a potential problem when used around the transverse processes of the thoracic and transverse
vertebrae?
FSIS is not currently restricting such manual deboning procedures. However, as noted in the January 12,
2003 interim final rule on SRM, FSIS is seeking comments on whether this procedure may contaminate meat
with an SRM. It is up to the plant to develop, implement, and maintain written procedures for the removal,
segregation, and disposition of SRMs. These procedures must be incorporated into the plant's HACCP plans,
SSOPs, or other pre-requisite program.
[Top of Page]
15. Is the shipping establishment required to provide documentation with every shipment?
The shipping establishment must include in their hazard analysis decisions on food safety hazards that
can occur before, during, and after entry into the establishment. The shipping establishment can ship
bone-in product with SRMs (e.g. vertebral columns) as long as they verify their removal in the receiving
establishment. In addition, the shipping establishment must provide documentation on every shipment of
product containing SRMs (e.g. vertebral columns from cattle 30 months and older) to the receiving
establishment. Please refer to Notice 4-04.
[Top of Page]
16. If the shipping establishment is removing all SRMs, is there a need to certify every shipment?
No. If the establishment is also shipping bone-in products from cattle under 30 months, they should provide
adequate documentation to the receiving establishment that verifies their SRM control programs. This would
not necessarily be needed on a shipment by shipment basis (see question 17).
[Top of Page]
17. Must a receiving establishment have certification from the shipping establishment if they are receiving
bone-in products?
One option that may be used is for the receiving establishment to have a letter from its supplier attesting
to the fact that product is from cattle under 30 months. However, as with E. coli O157:H7,
FSIS would expect the receiving establishment, as part of its prerequisite program, to perform on-going
verification. This can be accomplished by visiting or contacting the shipping plant on a quarterly
basis to verify the shipping plant's on-going commitment to its assurance. FSIS would also have the same
expectation with respect to assurances that the carcasses or parts shipped are from animals under 30 months.
[Top of Page]
18. Do the SRM regulations apply to custom slaughter? Can cattle be farm slaughtered and processed in custom facilities?
Specified Risk Materials are considered adulterated and are not eligible for human food—this applies to
custom products as well. Cattle can be farm slaughtered and processed in custom facilities, provided
they were not non-ambulatory disabled cattle, which are adulterated. The requirement for written control
programs does not apply to custom operators.
[Top of Page]
19. What is the FSIS policy on custom slaughter? For example, if a producer has an animal that he/she wants
killed for consumption by his/her own family, and the animal has a broken leg that won't allow it to
walk, can he/she take it to a custom plant and have it slaughtered for his/her own use, (i.e. not for sale)?
All non-ambulatory disabled cattle are to be precluded from the human food chain (i.e., condemned). This
determination is derived from the Title 1 Section 1 (m)(3) of the Federal Meat Inspection Act. Specifically,
The term "adulterated" shall apply to any carcass, part thereof, meat or meat food product under one or more of the following circumstances: if it consists in whole or in part of any filthy, putrid, or decomposed substance or is for any other reason unsound, unhealthful, unwholesome, or otherwise unfit for human food.
Ambulatory cattle may be custom slaughtered under our current regulations (9 CFR 303.1).
[Top of Page]
20. When an establishment has a non-ambulatory disabled cow they want to slaughter "custom exempt" at a
federally inspected facility, should the on-site FSIS inspector segregate it and call a VMO so it can be
condemned?
If the establishment is preparing to custom slaughter a non-ambulatory disabled cow (cattle) at a federally
inspected establishment, then the animal should be controlled by the inspector until the VMO can condemn it.
If the animal has not been presented for inspection, it could be removed from the premises without
permission from FSIS. (If FSIS personnel have reason to believe it will be taken elsewhere for slaughter—then
OPEER should be informed. The burden of proof is on FSIS).
[Top of Page]
|
See Also:
FSIS Further Strengthens Protections Against Bovine Spongiform Encephalopathy (BSE) |
Last Modified: March 19, 2004 |
|
|
|
|
|